No abstract

1. A 2x2 factorial design was used to test the hypothesis that impaired intestinal starch digestibility is attributable to rapid passage of digesta from the gizzard to the intestine, and that compared to steam pelleting, increasing the availability of starch through extrusion cooking may alleviate the potential negative effect of rapid digesta flow on starch utilisation. 2. Thus, 7-d-old broilers chickens were distributed to 48 cages and given a wheat-based (WB) pelleted diet containing either coarse oat hulls (OH-Pel) or fine cellulose (Cel-Pel) until d 19 to stimulate divergent development of the gizzard. Thereafter, both groups were further subdivided and challenged with a WB diet with cellulose in either pelleted (Cel-Pel) or extruded (Cel-Ext) form on d 20 and 22. Either excreta or intestinal contents were collected at time intervals after feeding and analysed for marker and starch. 3. OH-Pel increased gizzard size and holding capacity. No excessively high starch levels (max 25 g/kg) were detected in the excreta. However, 8 h feed-deprived birds given Cel-Pel and challenged with Cel-Pel exhibited higher starch-excretion and showed large individual variation during the first 135 min of collection.4. Contrary to OH-Pel group, more digesta and starch passed to the jejunum at 1 and 2 h and ileum at 2 and 3 h after feeding for birds given Cel-Pel, resulting in lower jejunal and ileal starch digestibility. 2 5. Increased starch gelatinisation through extrusion processing significantly improved starch digestibility regardless of gizzard function. However, at 1, 2 and 3 h after feeding, more digesta was retained in the foregut of birds given Cel-Ext.6. The current data showed that starch degradation rate is associated with the flow of digesta which is linked to gizzard development and that enzymatic hydrolysis of intact starch granules may be limited with more rapid feed passage through the gut.

1. A 2 × 2 factorial arrangement was used to test the hypothesis that, in pelleted diets, legume starch is digested less rapidly and to a lesser extent than cereal starch, and that increased gelatinisation through extrusion would eliminate the differences between the starch sources. In addition, the trial examined whether a lower ratio of starch to nitrogen disappearance rate (SNDR) could improve feed conversion ratio (FCR). 2. At 17 d of age, male broilers were randomly distributed among four dietary treatments, consisting of either wheat or faba bean starch-rich fraction (FBS) as the sole starch source and pelleting or extrusion as processing methods. Each treatment had 10 replicate pens containing five birds each. 3. Extrusion resulted in a more extensive starch gelatinisation compared to pelleting, as expected. 4. No difference in weight gain at 29 d of age was observed between birds fed starch sources. However, birds fed wheat tended (P = 0.080) to have better FCR than those fed FBS, while the effect of processing methods was insignificant. Thus, there was no interaction between starch source and processing method on FCR. 5. In pelleted diets, FBS had lower and slower starch digestibility compared to wheat in all intestinal segments (P < 0.05). The interaction between starch source and processing method in all intestinal segments (P < 0.001) demonstrated that FBS responded more to gelatinisation through extrusion than did wheat. Thus, differences in starch digestibility between the wheat and FBS were eliminated with extrusion. 6. Feeding extruded diets significantly increased the upper jejunal expression of GLUT1, GLUT2 and SGLT1 compared to pelleted diets, which suggested that glucose absorption was less likely to be a limiting factor for starch utilisation. 7. Pelleting resulted in a lower ratio (P < 0.001) of SNDR compared to extrusion (on average 1.4-fold) but did not improve FCR.

1. An in vitro test to study the effect of pH reduction on phytic acid degradation over time for four commercial phytases was conducted. Changing the pH level affected phytate degradation over time differently for the various phytases (P < 0.05). 2. The phytase with the largest response of pH reduction in the in vitro test and a feed pH level of 4.5 was chosen for the broiler experiment. The effect of intermittent feeding, addition of 500 FYT C. braakii-derived phytase and 1% formic acid were tested in a 2 x 2 x 2 factorial arrangement. Ten pens containing 10 birds each were fed each of the treatment combinations from 15 to 36 d of age. Ad libitum fed birds had two 4-h dark periods with 2-h light in-between, while intermittently fed birds in addition had restricted access to the feed through except for four 1-h and one 2-h feeding bouts.3. In addition to assessing performance, excreta were collected on a pen basis. The tibia and contents from jejunum and ileum were collected from one bird per pen. In addition, crop contents were collected from the intermittently fed birds 80, 160 and 240 min after the start of feeding. 4. Phytase improved performance, ileal and jejunal P digestibility, P retention and tibia ash and P concentration (P < 0.001). Intermittent feeding increased jejunal P digestibility and P retention (P < 0.001), but ileal P digestibility increased only in the intermittently fed birds compared to the ad libitum fed birds without phytase addition (P = 0.025). Acidification increased jejunal P digestibility only in the ad libitum fed birds (P = 0.019). There was a considerable inositol hexakisphosphate degradation into lower isomers in the crop after 80 min for diets with phytase (InsP 3 and 4 :P < 0.001), and acidification further increased this degradation (InsP 4 :P = 0.007). After 160 min retention time, the effect of phytase and acidification was even higher with more significant (P < 0.05) interactions. 5. The current data showed that prolonged retention time in the crop combined with feed acidification increased phytase efficacy by improving the phytate degradation.

1. A series of experiments were carried out to study the effect of grit on broiler performance, gizzard development and fate of grit in the digestive tract. 2. In Experiment 1, performance, gizzard weight and content of grit in the gizzard of broiler chickens given access to granite-type grit was investigated. In Experiment 2, the effect of grit stones on performance and gizzard development was assessed in diets with or without whole wheat. 3. In Experiment 3, the effect of grit in the form of zeolite, granite or marble on gizzard development and digestive tract grinding and passage was studied in diets with or without whole wheat. 4. Grit stones had no effect on performance of broiler chickens, which may be explained by the fact that grit stones did not stimulate gizzard development to the same extent as with other structural materials. 5. The lack of stimulation is at least partly due to the fact that a majority of the grit stones eaten pass through the small intestine without being retained in the gizzard. 6. Grit in the form of marble reduced feed intake and weight gain.