Water-soluble dietary fiber provides numerous health benefits. A novel procedure to efficiently manufacture water-soluble indigestible polysaccharides was developed by heating glucose at 180 C in the presence of activated carbon. Aside from its ability to catalytically assist the polycondensation of saccharides, activated carbon provides the added benefits of being easily separable from the reactants and suppressing coloration of the product. Prior to purification, the indigestible fraction made up over 80% of the reaction mixture. After hydrolysis catalyzed by α-amylase and glucoamylase, and fractionation by ionexchange chromatography, a total of 99.7% dietary fiber content was attained. This indigestible fraction, termed resistant glucan, was only minimally degraded by upper digestive tract enzymes, similar to the digestibility of polydextrose. Structural analysis by methylation and NMR indicated that the resistant glucan formed a highly branched structure containing α-and β-1,2-, 1,3-, 1,4-, and 1,6-linkages. On an industrial scale, the resistant glucan was obtained from glucose syrup (DE 86) by heating with activated carbon, enzymatic hydrolysis, refining, fractionating, and drying. Our facile method is an efficient means to obtain water-soluble dietary fiber.

No abstract

Carbohydrate materials that produce lower postprandial blood glucose increase are required for diabetic patients. To develop slowly digestible carbohydrates, the effect of degree of polymerization (DP) of α-1,6 glucan on its digestibility was investigated in vitro and in vivo. We prepared four fractions of α-1,6 glucan composed primarily of DP 3-9, DP 10-30, DP 31-150, and DP 151+ by fractionating a dextran hydrolysate. An in vitro experiment using digestive enzymes showed that the glucose productions of DP 3-9, DP 10-30, DP 31-150, and DP 151+ were 70.3, 53.4, 28.2, and 19.2 % in 2 h, and 92.1, 83.9, 39.6, and 33.3 % in 24 h relative to dextrin, respectively. An in vivo glycemic response showed that the incremental area under the curve (iAUC) of blood glucose levels of α-1,6 glucan with DP 3-9, DP 10-30, DP 31-150, and DP 151+ were 99.5, 84.3, 65.4, and 40.1 % relative to dextrin, respectively. These results indicated that α-1,6 glucan with higher DP had stronger resistance to digestion and produced a smaller blood glucose response. DP 10-30 showed significantly lower maximum blood glucose levels than dextrin; however, no significant difference was observed in iAUC, indicating that DP 10-30 was slowly digestible. In addition, α-1,6 glucan was also produced using an enzymatic reaction with dextrin dextranase (DDase). This produced similar results to DP 10-30. The DDase product can be synthesized from dextrin at low cost. This glucan is expected to be useful as a slowly digestible carbohydrate source.

No abstract

Slowly digestible carbohydrates are needed for nutritional support in diabetic patients with malnutrition. They are a good source of energy and have the advantage that their consumption produces a low postprandial peak in blood glucose levels because they are slowly and completely digested in the small intestine. A high-amount isomaltomegalosaccharide containing carbohydrate (H-IMS), made from starch by dextrin dextranase, is a mixture of glucose polymers which has a continuous linear structure of α-1,6-glucosidic bonds and a small number of α-1,4-glucosidic bonds at the reducing ends. It has a broad degree of polymerization (DP) distribution with glucans of DP 10 30 as the major component. In our previous study, H-IMS has been shown to exhibit slow digestibility in vitro and not to raise postprandial blood glucose to such levels as that raised by dextrin in vivo. This marks it out as a potentially useful slowly digestible carbohydrate, and this study aimed to evaluate its in vivo digestibility. The amount of breath hydrogen emitted following oral administration of H-IMS was measured to determine whether any indigestible fraction passed through to and was fermented in the large intestine. Total carbohydrate in the feces was also measured. H-IMS, like glucose and dextrin, did not result in breath hydrogen excretion. Carbohydrate excretion with dietary H-IMS was no different from that of glucose or water. These results show that the H-IMS is completely digested and absorbed in the small intestine, indicating its potential as a slowly digestible carbohydrate in the diet of diabetic patients.