This paper identifies the spatial extent of bauxite processing residue (red mud)-derived contaminants and modes of transport within the Marcal and Rába river systems after the dike failure at Ajka, western Hungary. The geochemical signature of the red mud is apparent throughout the 3076 km² Marcal system principally with elevated Al, V, As, and Mo. Elevated concentrations of Cr, Ga, and Ni are also observed within 2 km of the source areas in aqueous and particulate phases where hyperalkalinity (pH < 13.1) is apparent. Although the concentrations of some trace elements exceed aquatic life standards in waters (e.g., V, As) and fluvial sediments (As, Cr, Ni, V), the spatial extent of these is limited to the Torna Creek and part of the upper Marcal. Source samples show a bimodal particle size distribution (peaks at 0.7 and 1.3 μm) which lends the material to ready fluvial transport. Where elevated concentrations are found in fluvial sediments, sequential extraction suggests the bulk of the As, Cr, Ni, and V are associated with residual (aqua-regia/HF digest) phases and unlikely to be mobile in the environment. However, at some depositional hotspots, association of As, Cr, and V with weak acid-extractable phases is observed.

Results are presented from X-ray absorption spectroscopy based analysis of As, Cr, and V speciation within samples of bauxite ore processing residue (red mud) collected from the spill site at Ajka, Western Hungary. Cr K-edge XANES analysis found that Cr is present as Cr(3+) substituted into hematite, consistent with TEM analysis. V K-edge XANES spectra have E(1/2) position and pre-edge features consistent with the presence of V(5+) species, possibly associated with Ca-aluminosilicate phases. As K-edge XANES spectra identified As present as As(5+). EXAFS analysis reveals arsenate phases in red mud samples. When alkaline leachate from the spill site is neutralized with HCl, 94% As and 71% V are removed from solution during the formation of amorphous Al-oxyhydroxide. EXAFS analysis of As in this precipitate reveals the presence of arsenate Al-oxyhydroxide surface complexes. These results suggest that in the circumneutral pH, oxic conditions found in the Torna and Upper Marcal catchments, incorporation and sorption, respectively, will restrict the environmental mobility of Cr and As. V is inefficiently removed from solution by neutralization, therefore, the red mud may act as a source of mobile V(5+) where the red mud deposits are not removed from affected land.

No abstract

Red mud leachate (pH 13) collected from Ajka, Hungary is neutralized to < pH 10 by HCl, gypsum, or seawater addition. During acid neutralization >99% Al is removed from solution during the formation of an amorphous boehmite-like precipitate and dawsonite. Minor amounts of As (24%) are also removed from solution via surface adsorption of As onto the Al oxyhydroxides. Gypsum addition to red mud leachate results in the precipitation of calcite, both in experiments and in field samples recovered from rivers treated with gypsum after the October 2010 red mud spill. Calcite precipitation results in 86% Al and 81% As removal from solution, and both are nonexchangeable with 0.1 mol L(-1) phosphate solution. Contrary to As associated with neoformed Al oxyhydroxides, EXAFS analysis of the calcite precipitates revealed only isolated arsenate tetrahedra with no evidence for surface adsorption or incorporation into the calcite structure, possibly as a result of very rapid As scavenging by the calcite precipitate. Seawater neutralization also resulted in carbonate precipitation, with >99% Al and 74% As removed from solution during the formation of a poorly ordered hydrotalcite phase and via surface adsorption to the neoformed precipitates, respectively. Half the bound As could be remobilized by phosphate addition, indicating that As was weakly bound, possibly in the hydrotalcite interlayer. Only 5-16% V was removed from solution during neutralization, demonstrating a lack of interaction with any of the neoformed precipitates. High V concentrations are therefore likely to be an intractable problem during the treatment of red mud leachates.

No abstract