Yogurt was made using an exopolysaccharide-producing strain of Streptococcus thermophilus and its genetic variant that only differed from the mother strain in its inability to produce exopolysaccharides. The microstructure was investigated using confocal scanning laser microscopy, allowing observation of fully hydrated yogurt and the distribution of exopolysaccharide within the protein network. Yogurt made with the exopolysaccharide-producing culture exhibited increased consistency coefficients, but lower flow behavior index, yield stress, viscoelastic moduli and phase angle values than did yogurt made with the culture unable to produce exopolysaccharide. The exopolysaccharides, when present, were found in pores in the gel network separate from the aggregated protein. These effects could be explained by the incompatibility of the exopolysaccharides with the protein aggregates in the milk. Stirring affected the yogurt made with exopolysaccharide differently from yogurt without exopolysaccharide, as it did not exhibit immediate syneresis, although the structural breakdown was increased. The shear-induced microstructure in a yogurt made with exopolysaccharide-producing culture was shown to consist of compartmentalized protein aggregates between channels containing exopolysaccharide, hindering syneresis as well as the buildup of structure after stirring.

The aim of the present investigation was to study the underlying causes of noncoagulating (NC) milk. Based on an initial screening in a herd of 53 Danish Holstein-Friesians, 20 individual Holstein-Friesian cows were selected for good and poor chymosin-induced coagulation properties; that is, the 10 cows producing milk with the poorest and best coagulating properties, respectively. These 20 selected cows were followed and resampled on several occasions to evaluate possible changes in coagulation properties. In the follow-up study, we found that among the 10 cows with the poorest coagulating properties, 4 cows consistently produced poorly coagulating (PC) or NC milk, corresponding to a frequency of 7%. Noncoagulating milk was defined as milk that failed to form a coagulum, defined as increase in the storage modulus (G') in oscillatory rheometry, within 45min after addition of chymosin. Poorly coagulating milk was characterized by forming a weak coagulum of low G'. Milk proteomic profiling and contents of different casein variants, ionic contents of Ca, P and Mg, κ-casein (CN) genotypes, casein micelle size, and coagulation properties of the 4 NC or PC samples were compared with milk samples of 4 cows producing milk with good coagulation properties. The studies included determination of production of caseinomacropeptide to ascertain whether noncoagulation could be ascribed to the first or second phase of chymosin-induced coagulation. Caseinomacropeptide was formed in all 8 milk samples after addition of chymosin, indicating that the first step (cleavage of κ-CN) was not the cause of inability to coagulate. Furthermore, the effect of mixing noncoagulating and well-coagulating milk was studied. By gradually blending NC with well-coagulating milk, the coagulation properties of the well-coagulating samples were compromised in a manner similar to titration. Milk samples from cows that consistently produced NC milk were further studied at the udder quarter level. The coagulation properties of the quarter milk samples were not significantly different from those of the composite milk sample, showing that poor coagulation traits and noncoagulation traits of the composite milk were not caused by the milk quality of a single quarter. The milk samples exhibiting PC or NC properties were all of the κ-CN variant AA genotype, and contained casein micelles with a larger mean diameter and a lower fraction of κ-CN relative to total CN than milk with good coagulation properties. Interestingly, the relative proportions of different phosphorylation forms of α-CN differed between well-coagulating milk and PC or NC milk samples. The PC and NC milk samples contained a lower proportion of the 2 less-phosphorylated variants of α-CN (α(S1)-CN-8P and α(S2)-CN-11P) compared with samples of milk that coagulated well.

No abstract

Gelation of α-lactalbumin (α-la) incubated with a protease from Bacillus licheniformis (BLP) at 50 °C for 4 h was monitored using small oscillatory shear and the large deformation properties of final gels were characterized by uniaxial compression. Transmission electron microscopy was used to visualize the microstructure. Gels made from α-la (10 g/l) using BLP were almost transparent, although somewhat whitish, and they were more than 20 times stiffer (measured as complex modulus) than equivalent gels made from β-lactoglobulin (β-lg) at the same concentration. The microstructure of the gels consisted of non-branching, apparently hollow strands with a uniform diameter close to 20 nm, similar in overall structure to microtubules. Adding Ca2+ in amounts of 50 or 100 mM changed the spatial distribution of the strands and resulted in a reduction in the failure stress recorded in uniaxial compression. Apart from affecting the microstructure, Ca2+ was shown to be essential for the formation of the gels. It is proposed, that the mechanism behind the self-assembly of the partially hydrolysed α-la into long tubes is a spatially restricted creation of ionic bonds between Ca2+ and carboxyl acid groups on peptide fragments resulting from the action of BLP on α-la. Proteolysis of α-la with BLP in the presence of Ca2+ thus results in formation of a strong gel with a microstructure not previously observed in food protein systems.

Two lines of transgenic potato (Solanum tuberosum L.) plants modified in their cell wall structure were characterized and compared to wild type with regard to biomechanical properties in order to assign functional roles to the particular cell wall polysaccharides that were targeted by the genetic changes. The targeted polymer was rhamnogalacturonan I (RG-I), a complex pectic polysaccharide comprised of mainly neutral oligosaccharide side chains attached to a backbone of alternating rhamnosyl and galacturonosyl units. Tuber rhamnogalacturonan I molecules from the two transformed lines are reduced in linear galactans and branched arabinans, respectively. The transformed tuber tissues were found to be more brittle when subjected to uniaxial compression and the side-chain truncation was found to be correlated with the physical properties of the tissue. Interpretation of the force-deflection curves was aided by a mathematical model that describes the contribution of the cellulose microfibrils, and the results lead to the proposition that the pectic matrix plays a role in transmitting stresses to the load-bearing cellulose microfibrils and that even small changes to the rheological properties of the matrix have consequences for the biophysical properties of the wall.