In canned anchovies the moisture content after salting decreased from 75.5% to 54%.The loss was accompanied by an increase in salt and ash contents. Free fatty acid (FFA) contents increased gradually throughout ripening. The FFA content variability was too wide to consider it as an index to monitor ripening. Although peroxide and TBA values provide an indication of onset of lipid oxidation, alternative methods are recommended based on tertiary compounds of lipid oxidation. Total volatile basic nitrogen (TVB-N) increased linearly in fish muscle and brine during ripening. TVB-N determination in the brine could be a feasible monitoring method for degree of ripening.

Histamine production was studied during controlled tunafish decomposition at 0, 8, and 20°C. The influence of the location of the anatomic section on the amount of histamine formed and the incidence of histidine decarboxylating bacteria were also considered. By the time of sensory rejection, histamine levels in tunafish sections stored at 0 and 20°C were still below the hazard levels and the allowable levels established by both the U.S. Food and Drug Administration (FDA) and the European Union. Toxic amounts were only formed after the tunafish was considered organoleptically unsuitable for human consumption. However, at 8°C, levels of histamine between 100 and 200 mg/l00 g of fish were found before tuna reached the rejection point. Hence, physical appearance was not a good criterion for estimating the shelf life and especially the histamine-related health hazard when tuna was stored at 8°C, a common temperature in many home refrigerators.

This study was performed to investigate halotolerant and halophilic histamine-producing bacteria isolated during the ripening of salted anchovies. Of the isolates obtained during the ripening of anchovies, 1.37% showed histamine-forming activity, most of them (70%) belonging to the Staphylococcus genus. S. epidermidis showed a powerful histamine-forming activity, producing more than 1,000 microg/ml in the presence of 3% and 10% NaCl. Another powerful histamine-producing bacterium isolated during the ripening of salted anchovies was S. capitis. It was able to produce about 400 microg/ml of histamine in 10% NaCl under experimental conditions. Most of these species might be expected to be found as a result of contamination of fish during capture and subsequent unhygienic handling. However, no increase in histamine content was found in any batches through the ripening process. Histamine content always was acceptable in accordance with the maximum allowable levels of histamine fixed by the Spanish and European Union regulations.

No abstract

The present paper analyzes the bacteriological quality and histamine content of tuna fish samples destined for canning. Raw material used in the canning process was of good quality. Histamine-producing bacteria counts were only found in three samples from the last step of the canning process before sterilization. Most of the bacteria identified as histamine formers were gram negative, and nearly all of which belonged to the Enterobacteriaceae family. Morganella morganii was the most frequent and active histamine former in tuna fish destined for canning. Other powerful histamine-producing bacteria isolated during the canning operation were Klebsiella oxytoca, Klebsiella pneumoniae and some strains of Enterobacter cloacae and Enterobacter aerogenes. They all were able to produce more than 500 ppm of histamine in experimental conditions. Most of these species might be expected to be found as a result of contamination of fish during capture and subsequent unhygienic handling in the canning plant. An increase in histamine content in tuna meat was not expected through the canning process. Histamine content always was acceptable in accordance with the maximum allowable levels of histamine fixed by both the European Economic Community and Food and Drug Administration.