Many waxes including plant waxes and animal waxes were evaluated for the gelation ability toward soybean oil (SBO) and compared with hydrogenated vegetable oils, petroleum waxes and commercial non-edible gelling agents to understand factors affecting the gelation ability of a gelator. Sunflower wax (SW) showed the most promising results and all SW samples from three different suppliers could make a gel with concentrations as low as 0.5 wt%. Candelilla wax and rice bran wax also showed good gelation properties, which, however, varied with different suppliers. Gelation ability of a wax is significantly dependant on its purity and detailed composition. A wax ester with longer alkyl chains has significantly better gelation ability toward SBO than that with shorter alkyl chains indicating that the chain length of a component in a wax such as wax ester is an important factor for gelation ability. The SW-SBO organogel showed increased melting point with increased SW content, showing the melting point range from about 47 to 65°C with 0.5-10 wt% SW. The effects of cooling rate on crystal size and firmness of a gel were investigated. The dependence of firmness on cooling rate was so significant that the desired texture of an organogel could be achieved by controlling the cooling rate in addition to controlling the amount of gelling agent. This research reveals that a small amount of food grade plant waxes including SW may replace a large amount of the hardstock containing trans-fat or saturated fat.

No abstract

Organogels obtained from plant wax and soybean oil were tested for their suitability for incorporation into margarine. Sunflower wax, rice bran wax and candelilla wax were evaluated. Candelilla wax showed phase separation after making the emulsion with the formulation used in this study. Rice bran wax showed relatively good firmness with the organogel, but dramatically lowered firmness for a margarine sample. Sunflower wax showed the greatest firmness for organogel and the margarine samples among the three plant waxes tested in this study. Firmness of the margarine containing 2-6 % sunflower wax in soybean oil was similar to that of margarine containing 18-30 % hydrogenated soybean oil in soybean oil. The firmness of commercial spread could be achieved with about 2 % sunflower wax and that of commercial margarine could be achieved with about 10 % of sunflower wax in the margarine formulation. Dropping point, DSC and solid fat content of the new margarine containing 2-6 % sunflower wax showed a higher melting point than commercial margarine and spreads.

No abstract

To be able to tailor and optimize the physical properties of oleogels for various food applications, more information is needed to understand how different gelators interact. Therefore, the objectives of this study were to evaluate the interactions between binary mixtures of beeswax (BW), candelilla wax (CLW), and sunflower wax (SFW) in pure form as well as in 5% wax oleogels made with soybean oil, in terms of their crystallization and melting properties, crystal morphology, solid fat content, and gel firmness. CLW:BW mixtures had eutectic melting properties, and oleogels from these mixtures with 40:60 to 90:10 CLW:BW were firmer compared to oleogels made with one wax. The main components in SFW and BW appeared to cocrystallize or crystallize at the same temperature, but nonlinear changes in melting point and solid fat content profile of oleogels prepared with the mixed waxes indicated that SFW dominated oleogel formation. In addition, oleogels prepared with mixtures of SFW and BW had lower firmness compared to oleogels prepared with one wax, indicating an incompatibility between the two waxes. The main wax components in SFW and CLW never cocrystallized, and low levels of CLW appeared to prevent SFW from forming a crystalline platelet network. This resulted in low firmness of oleogels made from mixtures of 90:10 to 60:40 SFW:CLW compared to oleogels prepared with one wax. However, the firmest oleogels of all mixtures were made from 10:90 SFW:CLW. Changes in gel firmness and melting properties with mixed wax oleogels were likely to be due to changes observed in the crystal size and morphology. In addition, the firmest gels were shown to result from mixtures that were predicted to have >40% hydrocarbon content, and a high hydrocarbon to wax ester ratio, but minor components such as free fatty acids and fatty alcohols may have also influenced firmness.

This study showed that sunflower wax could be used as an alternative to traditional solid fats for the development of new margarine and spread products from a variety of healthy vegetable oils.

No abstract

The aim of this study is to evaluate the oleogel (or organogel) technology as a new method to prevent oxidation of fish oil by immobilizing oil and to provide useful information on oxidation of oleogels for their application in actual food products. Four different natural waxes, rice bran wax, sunflower wax, candelilla wax, and beeswax are used to prepare fish oil oleogels. Peroxide value, conjugated diene value, eicosapentaenoic acid (EPA), and docosahexaenoic acid (DHA) are measured after storing oleogels at 35 and 50 °C, respectively. All 3% wax‐fish oil oleogels shows slower oxidation than the bulk fish oil at 35 °C. Beeswax is not as effective as other waxes during storage at 50 °C due to its lower melting point. The color penetration measurement method is developed as a convenient method to predict the oxidation rate of oleogel. Cooling oleogel at a faster rate can significantly reduce the oxidation rate of the oleogel. A larger amount of wax is not recommended to increase the protective effect, which can give a negative effect due to the prooxidant activity of wax. The oleogel technology may be applied to reduce oxidation of food products and nutritional supplements containing omega‐3 oil. Practical Application: This study clearly shows that the oleogel technology can be used to prevent oil oxidation by immobilizing oil in food products. This technology can be used for commercial products such as fish oil supplements to prevent oil oxidation during production, transportation, and storage. The information presented in this study can also be used for new omega‐3 oil fortified food products such as margarine, spreads, shortening, cookies, and other related products. The oleogel technology can be easily applied as a drop‐in method. Natural waxes used as oleogelator are inexpensive and widely available, and most of them are already used in many food products. Peroxide value of 3% wax‐fish oil oleogels stored at 35 °C for 7 days.