No abstract

No abstract

Dielectric properties of materials influence the interaction of electromagnetic fields with and are therefore important in designing effective dielectric heating processes. We investigated the dielectric properties (DPs) of pecan kernels between 10 and 3000 MHz using a Novocontrol broadband dielectric spectrometer in a temperature range of 5–65 °C and a moisture content range of 10–30% wet basis (wb) at three salt levels. The dielectric constant (ε′) and loss factor (ε″) of the pecan kernels decreased significantly with increasing frequency in the radio frequency (RF) band, but gradually in the measured microwave (MW) band. The moisture content and temperature increase greatly contributed to the increase in the ε′ and ε″ of samples, and ε″ increased sharply with increasing salt strength. Quadratic polynomial models were established to simulate DPs as functions of temperature and moisture content at four frequencies (27, 40, 915, and 2450 MHz), with R2 > 0.94. The average penetration depth of pecan kernels in the RF band was greater than that in the MW band (238.17 ± 21.78 cm vs. 15.23 ± 7.36 cm; p < 0.01). Based on the measured DP data, the simulated and experimental temperature-time histories of pecan kernels at five moisture contents were compared within the 5 min RF heating period.

The fresh Chinese hickory nuts (Carya cathayensis sarg.) were exposed to airborne ultrasound‐assisted convective drying and microwave‐assisted convective drying, as well as their combination. We investigated the effect of different drying schemes on process kinetics and quality characteristics. The global model of drying kinetics based on coupled ordinary differential equations was used to describe the moisture and material temperature profiles during drying. Application of ultrasound and microwave in convective drying reduced drying time in the range of 14.0–56.6%, but the maximum savings was found for simultaneous exposure of convection, ultrasound, and microwave with the range of 73.6–84.2%. The globally mathematical model was successfully used to simulate the real drying kinetics processes. The quality properties about the content of heat‐sensitive bioactive substances such as phenolic, flavonoid, proanthocyanidin, individual phenolic compounds, as well as antioxidant capacity in convective drying assisted with microwave (100 W) and ultrasound (200 W; CU2M1) are found to be significantly higher than the other groups. The results allow stating ultrasound increase drying efficiency, as expected by reducing the drying time there is less damage to the product. Practical Application In this work, we designed an experimental scale hybrid dryer that equipped with hot‐air convective drying, ultrasound generator and microwave drying system to dehydrate Chinese hickory nut and the effect of different drying schemes on the drying kinetics and product characteristics were investigated. This is an innovative technology of microwave and ultrasound hybrid drying to produce dried hickory products. Application of ultrasound and microwave in convective drying reduced drying time in the range of 14–56.6%, but the shortest drying time was observed for simultaneous action of convection, ultrasound, and microwave. The results of qualitative analysis showed a product improvement due to ultrasound as compared to convective drying and microwave‐convective drying.

In this work, red quinoa was successively subjected to α‐amylase steaming, complex enzyme Viscozyme (R) L hydrolysis, and lactic acid bacteria (LAB) fermentation. The total phenolic compound content (TPC), flavonoid content (TFC), and antioxidant capacities of the solvent‐extractable (free) and bound fractions and the individual phenolic compounds released were determined. Compared to steaming with α‐amylase, enzymatic hydrolysis and fermentation of quinoa resulted in approximately 82.6, 26.9, 36.3, and 45.2% increases in the TPC (the sum of free and bound fractions), TFC, DPPH, and ORAC values, respectively. HPLC‐QqQ‐MS/MS analysis showed that enzymolysis and fermentation increased the content of protocatechuic acid, catechin, procyanidin B2, and quercetin by 126.3, 101.9, 524, and 296.3%, respectively. Moreover, a major proportion of individual phenolic compounds existed as bound form. The results indicated that complex enzymatic hydrolysis and LAB fermentation were practical and useful to release promising polyphenols. This research provides a basis for the processing of quinoa beverages rich in phenolic compounds. Practical Application In this work, liquefying with α‐amylase, hydrolyzing with cellulolytic enzyme mixture, and fermenting with Lactic acid bacteria (LAB), successively, were exploited to process quinoa. This is an innovative method of quinoa processing to produce beverage products. Complex enzymatic hydrolysis and fermentation with LAB can significantly enhance phenolic compound, especially protocatechuic acid, catechin, procyanidin B2, and quercetin. In additional, LAB fermentation is very beneficial to improve the antioxidant activity of quinoa. We also found that a major proportion of phenolic compounds existed as bound forms in quinoa.