The inclusion of PepSoyGen (PSG), a commercially-available fermented soybean meal product, was evaluated with juvenile rainbow trout, Oncorhynchus mykiss in an initial 70-day feeding trial, with a supplemental trial involving a subset of the experimental diets continuing for an additional 40 d. Six diets containing 0%, 10%, 20%, 30%, 40%, or 50% PSG, with the PSG directly replacing fish meal, were used in the first trial. There were no significant differences in weight gain or feed conversion ratio between the fish meal-based control diet and diets containing up to 30% PSG. However, weight gain was significantly reduced and feed conversion ratio significantly increased with the 40% and 50% PSG diets. No health assessment differences were observed in fish receiving any of the diets, and no evidence of gross gut inflammation was evident. There were no significant differences in weight gain or feed conversion ratio among the four dietary treatments ranging from 0% to 30% PSG which were fed for an additional 40 d after the initial 70-d trial (110 days total). Based on these results, juvenile rainbow trout diets can contain up to 30% PSG without any loss of rearing performance, thereby replacing at least 60% of the fish meal.

Juvenile rainbow trout Oncorhynchus mykiss diets containing PepSoyGen, a commercially-available fermented soybean meal product, were supplemented with methionine and other amino acids. A fish meal-based control and four experimental diets were used in a 36-day feeding trial; two diets contained 40% PepSoyGen and 10% fish meal, and two diets contained 50% PepSoyGen and no fish meal. Each of these diets was supplemented with either methionine, or methionine and additional amino acids. One mortality was observed during the trial. Overall weight gain, percent gain, and feed conversion ratio were significantly greater for the fish meal control than for any of the PepSoyGen diets, although feed conversion ratios from all of the diets were still below 1. Apparent protein digestibility was significantly less in the fish receiving the control diet compared to any of the experimental diets, and significantly increased with increasing PepSoyGen concentrations. There was no significant difference in length, weight, condition factor, hepatosomatic index, viscerosomatic index, or any fish health responses among dietary treatments. Fillet composition, as determined by crude protein, crude lipid, water, and ash, was also not significantly different among fish reared on any of the diets. The supplementation of other amino acids in addition to methionine had no noticeable effect. The results from this study indicate that PepSoyGen with amino acid supplementation can completely replace fish meal in juvenile rainbow trout grower diets over a relatively short time-frame, albeit with some decrease in rearing performance.

Five studies were conducted to determine nutrient digestibility and performance of lambs and steers fed thermochemically treated crop residues and distillers dried grains with solubles (DDGS) as a corn replacement pellet (CRP; 75% residue:25% DDGS, DM basis). Fifteen Hampshire, Suffolk, or Dorset wethers (BW 33.3 +/- 5.0 kg) were utilized to evaluate nutrient digestibility of the unprocessed native (NAT) and CRP [Exp. 1: wheat straw (WS); Exp. 2: corn stover (CS); Exp. 3: switchgrass (SWG) and corn fiber:wheat chaff (CFWC)] when limit fed (Exp. 1 and 2: 1.8% of BW daily; Exp. 3: 2.5% of BW daily) compared with a 60% corn diet. In Exp. 4, 56 individually fed Dorset-cross wether lambs (BW 32.0 +/- 1.4 kg) were utilized to compare performance and digestibility of WS, wheat chaff (WC), corn fiber (CF), a 3:1 blend of corn fiber:wheat straw (CFWS), a 3:1 blend of CFWC, and SWG-CRP fed for ad libitum intake compared with a 45% corn diet. In Exp. 5, 32 individually fed Holstein steers (BW 185.2 +/- 0.9 kg) were used to evaluate performance and digestibility of diets containing corn, WS-CRP, CFWC-CRP, or NAT-WS fed for ad libitum intake. Crop residues were processed with 5% calcium oxide (DM basis) and 35% water in a double-shaft enclosed mixer (Readco Kurimoto Continuous Processor, York, PA) and subsequently pelleted with DDGS to form CRP. Feeding lambs WS-CRP (Exp. 1) or CS-CRP (Exp. 2) increased digestion of DM, NDF, and ADF compared with NAT (P < 0.05). In Exp. 3, feeding CFWC-CRP increased total tract NDF digestibility and ADF digestibility (P < 0.05). Experiment 4 final BW were greatest for control lambs and least for lambs fed CFWS-CRP or SWG-CRP. Body weight gains for lambs fed CRP averaged 15.9% less than control (P < 0.05). Lambs fed CRP diets had greater (P < 0.05) NDF and ADF intake and output. In Exp. 5, steers fed the corn or 2 CRP diets gained similarly and faster (P < 0.05) than those fed the NAT-WS diet. Steers fed the control corn diet were more efficient (P < 0.05) than steers fed other treatments. Steers fed the corn diet, CFWC-CRP, and WS-CRP had greater (P < 0.01) DM digestibility than NAT. The results confirm benefits for nutrient digestion and subsequent animal performance when crop residues are thermochemically processed. Processed crop residues may be fed in combination with DDGS to partially replace corn in ruminant diets.