No abstract

First, we report the application of stable isotope dilution theory in metabolome characterization of aerobic glucose limited chemostat culture of S. cerevisiae CEN.PK 113-7D using liquid chromatography-electrospray ionization MS/MS (LC-ESI-MS/MS). A glucose-limited chemostat culture of S. cerevisiae was grown to steady state at a specific growth rate (mu)=0.05 h(-1) in a medium containing only naturally labeled (99% U-12C, 1% U-13C) carbon source. Upon reaching steady state, defined as 5 volume changes, the culture medium was switched to chemically identical medium except that the carbon source was replaced with 100% uniformly (U) 13C labeled stable carbon isotope, fed for 4 h, with sampling every hour. We observed that within a period of 1 h approximately 80% of the measured glycolytic metabolites were U-13C-labeled. Surprisingly, during the next 3 h no significant increase of the U-13C-labeled metabolites occurred. Second, we demonstrate for the first time the LC-ESI-MS/MS-based quantification of intracellular metabolite concentrations using U-13C-labeled metabolite extracts from chemostat cultivated S. cerevisiae cells, harvested after 4 h of feeding with 100% U-13C-labeled medium, as internal standard. This method is hereby termed "Mass Isotopomer Ratio Analysis of U-13C Labeled Extracts" (MIRACLE). With this method each metabolite concentration is quantified relative to the concentration of its U-13C-labeled equivalent, thereby eliminating drawbacks of LC-ESI-MS/MS analysis such as nonlinear response and matrix effects and thus leads to a significant reduction of experimental error and work load (i.e., no spiking and standard additions). By coextracting a known amount of U-13C labeled cells with the unlabeled samples, metabolite losses occurring during the sample extraction procedure are corrected for.

Metabolic-flux analyses in microorganisms are increasingly based on (13)C-labeling data. In this paper a new approach for the measurement of (13)C-label distributions is presented: rapid sampling and quenching of microorganisms from a cultivation, followed by extraction and detection by liquid chromatography-mass spectrometry of free intracellular metabolites. This approach allows the direct assessment of mass isotopomer distributions of primary metabolites. The method is applied to the glycolytic and pentose phosphate pathways of Saccharomyces cerevisiae strain CEN.PK113-7D grown in an aerobic, glucose-limited chemostat culture. Detailed investigations of the measured mass isotopomer distributions demonstrate the accuracy and information-richness of the obtained data. The mass fractions are fitted with a cumomer model to yield the metabolic fluxes. It is estimated that 24% of the consumed glucose is catabolized via the pentose phosphate pathway. Furthermore, it is found that turnover of storage carbohydrates occurs. Inclusion of this turnover in the model leads to a large confidence interval of the estimated split ratio.

A detailed stoichiometric model was developed for growth and penicillin‐G production in Penicillium chrysogenum. From an a priori metabolic flux analysis using this model it appeared that penicillin production requires significant changes in fluxes through the primary metabolic pathways. This is brought about by the biosynthesis of carbon precursors for the β‐lactan nucleus and an increased demand for NADPH, mainly for sulfate reduction. As a result, significant changes in flux partitioning occur around four principal nodes in primary metabolism. These are located at: (1) glucose‐6‐phosphate; (2) 3‐phosphoglycerate; (3) mitochondrial pyruvate; and (4) mitochondrial isocitrate. These nodes should be regarded as potential bottlenecks for increased productivity. The flexibility of these principal nodes was investigated by experimental manipulation of the fluxes through the central metabolic pathways using a high‐producing strain of P. chrysogenum. Metabolic fluxes were manipulated through growth of the cells on different substrates in carbon‐limited chemostat culture. Metabolic flux analysis, based on measured input and output fluxes, was used to calculate the fluxes around the principal nodes. It was found that, for growth on glucose, ethanol, and acetate, the flux partitioning around these nodes differed significantly. However, this had hardly any effect on penicillin productivity, showing that primary carbon metabolism is not likely to contain potential bottlenecks. Further experiments were performed to manipulate the total metabolic demand for the cofactor nicotinamide adenine dinucleotide phosphate (NADPH). NADPH demand was increased stepwise by cultivating the cells on glucose or xylose as the carbon source combined with either ammonia or nitrate as the nitrogen source, which resulted in a stepwise decrease of penicillin production. This clearly shows that, in penicillin fermentation, possible limitations in primary metabolism reside in the supply/regeneration of cofactors (NADPH) rather than in the supply of carbon precursors. © 2000 John Wiley & Sons, Inc. Biotechnol Bioeng 68: 602–618, 2000.