A study was conducted to evaluate the ability of the young (0 to 3 wk) broiler chicken to utilize the P provided by a high available P corn [HAPC; 0.27% total P and 0.17% nonphytate P] in comparison with yellow dent corn (YDC; 0.23% total P and 0.03% nonphytate P), and to determine the extent to which supplementation with exogenous phytase enzyme could reduce the demands for dietary P and subsequently reduce P excretion. Diets prepared using the two types of corn differed in the amount of phytate-bound P, with the HAPC diets containing approximately 50% less phytate-bound P. Treatment diets were prepared by varying the amount of dicalcium phosphate, and ranged from 0.10 to 0.50% nonphytate P for YDC diets, and from 0.18 to 0.50% nonphytate P for HAPC diets. Sublots of each diet were supplemented with 800 units/kg phytase. Each diet was fed to six pens of five male chicks of a commercial broiler strain from 1 to 21 d of age. Regression analysis was used to estimate nonphytate P requirements for each corn type with and without phytase supplementation. The greatest need for nonphytate P was for maximum tibia ash, with requirements of 0.39, 0.29, 0.37, and 0.32% in diets with YDC, YDC plus phytase, HAPC, and HAPC plus phytase, respectively. Addition of phytase liberated approximately 50% of the phytate-bound P from each diet. These levels were sufficient to support body weight, feed conversion, and livability. Fecal P content of broilers fed diets with YDC at the NRC (1994) recommended level of 0.45% nonphytate P was 1.21%, whereas at the respective requirement points indicated above, the P content was 1.09, 0.87, 0.78, and 0.64% in feces from broilers fed diets with YDC, YDC plus phytase, HAPC, and HAPC plus phytase, respectively. Thus, fecal P output could be reduced while maintaining optimum performance by the use of reduced dietary nonphytate P, introduction of HAPC, and phytase supplementation. One of the greatest benefits of phytase supplementation appeared to be maintaining livability at lower dietary levels of nonphytate P.

No abstract

Two studies of identical design were conducted in battery brooders utilizing male chicks of a commercial strain. The birds were grown to 3 wk on diets with adequate P and from 3 to 6 wk were fed diets ranging from 0.10 to 0.45% nonphytate P (nPP) in increments of 0.05%, with or without supplementation with 800 units of phytase per kilogram of diet. Measurements included BW gain, feed conversion ratio (FCR), mortality, tibia ash, and fecal P content. Nonlinear regression was used to estimate nPP needs for optimizing BW gain, feed conversion, and tibia ash. In the absence of phytase, nPP levels of 0.33, 0.186, and 0.163% were required to optimize tibia ash, BW gain, and FCR, respectively. The estimated level for optimum tibia ash is in close agreement with current NRC (1994) recommendations. In the presence of 800 units of phytase per kilogram, nPP levels of 0.24, 0.151, and 0.109% were needed to optimize tibia ash, BW gain, and FCR, respectively. Fecal phosphorus levels were markedly reduced at the lower P levels. Further studies are needed to determine whether maximum tibia ash values are needed to sustain optimum production of market broilers.

Two trials of similar design were conducted to determine the nonphytate phosphorus (NPP) requirements for broilers from 42 to 63 d of age in diets with or without phytase supplementation. Male broilers of a commercial strain were grown to 42 d on nutritionally complete diets with NRC (1994) recommended levels of Ca and NPP. At 42 d, the birds were placed on experimental diets and fed to 63 d. The experimental treatments consisted of a 2 x 6 factorial arrangement with two levels of phytase (0 or 800 U/kg) and six levels of NPP (0.10 to 0.35% in 0.05% increments). Body weight gain, feed conversion, and mortality were determined during the period. At 49, 56, and 63 d, excreta samples were taken, and samples of birds were killed for tibia ash determination. The lowest level of NPP, with or without phytase supplementation, was sufficient for maximum BW gain, feed conversion, and livability. Using nonlinear regression, levels of NPP needed to optimize tibia ash in the absence of phytase were 0.31 +/- 0.004%, 0.23 +/- 0.02%, and 0.22 +/- 0.029% at 49, 56, and 63 d, respectively. When diets were supplemented with 800 U/kg of phytase, the NPP requirement for optimum tibia ash was 0.15 +/- 0.049% at 49 d. At 56 and 63 d, no more than 0.10% NPP (lowest level tested) was sufficient to maximize tibia ash. Compared to current NRC (1994) recommendations, the application of these reduced dietary phosphorus levels could markedly reduce excreta excretion of phosphorus by broilers.

A study was conducted to determine the extent fecal P levels could be reduced while maintaining performance. Various strategies were employed including the use of a high available phosphorus hybrid of corn (HAPC), supplementation with phytase enzyme, and reduced dietary P levels. The use of HAPC resulted in a 50% reduction in phytate-bound dietary P as compared with a normal yellow dent corn (YDC) diet. Dietary nonphytate P was maintained at either NRC (1994) recommendations for appropriate age periods or reduced by 0.075 or 0.15%. Portions of the diets were supplemented with 1,000 units of phytase/kg. Male chicks of a commercial strain were grown to 56 d on the test diets. Broilers fed diets with HAPC had BW, feed conversion, livability, and tibia ash that were equal to or superior to those fed diets with YDC with considerably reduced fecal P content at any dietary level of nonphytate P. Phytase supplementation enabled birds to maintain live performance at lower levels of nonphytate P, further reducing the fecal P output. One of the greatest contributions of phytase was a reduction in mortality at the lower levels of nonphytate P. Dietary P levels could be reduced by 0.075% under NRC (1994) recommendations without adversely affecting live performance; a reduction of 0.15% in conjunction with phytase supplementation maintained BW, feed conversion, and livability but reduced tibia ash. The extent to which dietary P levels can be reduced over the entire feeding program is subject to further research.

Studies were conducted to evaluate spent hen meal (SHM) produced in commercial rendering plants as a nutrient source in diets for broiler chickens. Utilizing previously determined nutrient composition values, including digestible amino acid and TMEn content, diets were formulated to include 0, 5, 10, and 15% of SHM from three different locations. In the first experiment, conducted in battery pens from 1 to 21 d posthatch, diets were formulated with digestible amino acid requirements set at 90, 95, or 100% of NRC (1994) total amino acid requirements. In the second experiment, conducted in floor pens from 1 to 49 d posthatch, diets were formulated with digestible amino acid requirements set at 95% of NRC (1994) total amino acid requirements. Samples of birds from the second experiment were processed to determine the possible influence of SHM inclusion on carcass yield. Results of the present studies indicate that SHM from commercial rendering facilities can be utilized in diets for growing broiler chickens provided adjustments are made in nutrient content and digestibility. When formulated on the basis of digestible amino acid content, levels of SHM up to 10% appear acceptable based upon body weight, feed conversion, bone ash, and carcass yield. Higher inclusion rates generally reduced performance. It is apparent that differences in nutritional quality may exist among products produced by different rendering facilities; however, evaluation of products to assess nutrient quality may be difficult under commercial conditions. As more information is generated regarding typical amino acid content and digestibility of rendered SHM, the product may be used with greater confidence in commercial diets.

No abstract

No abstract