No abstract

The physicochemical properties of oil from Rosa affinis rubiginosa seeds were analyzed after extraction by (i) organic solvent, (ii) cold pressing, and (iii) cold pressing assisted by enzymatic pretreatment using a mixture of the Novo-Nordisk A/S products Cellubrix (cellulase and hemicellulase activities) and Olivex (pectinase, cellulase, and hemicellulase activities). There were no significant differences in oil quality parameters, such as iodine value, refractive index, saponification value, unsaponifiable matter, and FA profile, when applying any of the three extraction processes. Although significant variations were observed in FFA content (acid value) and PV of the oil obtained by both of the cold-pressing oil extraction processes, these results were lower than the maximum value established from the Codex Alimentarius Commission. All-trans-retinoic acid content improved by 700% in rosehip oil obtained through cold pressing, with and without enzymatic pretreatment, in comparison with organic solvent extraction. This result is quite important for cosmetic oil because all-trans-retinoic acid is the main bioactive component responsible for the regenerative properties of this oil.Paper no. J11343 in JAOCS 83, 771-775 (September 2006).

the authors showed that an enzymatic pretreatment of rose-hip seeds, prior to oil extraction by cold pressing, improves the oil yield. In this work, we studied the effects of temperature and moisture during the enzymatic hydrolysis stage using two previously selected mixtures of commercial enzymes: (i) Olivex (mainly pectinase) plus Cellubrix (mainly cellulase), and (ii) Finizym (mainly β-glucanase) plus Cellubrix (mainly cellulase) (all from Novozymes A/S, Madrid, Spain). In addition, we evaluated the effect of enzymatic hydrolysis on the oil extraction pressing rate at different operational pressures. Samples hydrolyzed enzymatically by either of the two commercial enzyme mixtures at 45°C and 30-40% moisture showed oil extraction yields up to 60%, an increase of greater than 50%, as compared with control samples in which the enzyme solutions were replaced by water. Both the oil extraction rate and yield by pressing increased when enzymatic pretreatment was applied. The oil extraction yield increased slightly when the operation pressure was elevated; however, when the sample was preheated, the oil extraction yield was greatly increased, especially for enzyme-treated samples. Results confirmed the importance of temperature and moisture as enzymatic hydrolysis parameters that improve rose-hip oil extraction yields in the cold-pressing process. When pressing was carried out after preheating enzymatically treated samples, it was possible to increase the oil extraction yield to 72% compared with the control without preheating, which resulted in a 46% oil yield.

No abstract