Previous studies have shown that RH during incubation of chicken eggs influences water loss from the egg and embryonic mortality. In those studies, eggshell temperatures (EST) were not monitored or controlled. Because RH influences the egg's heat loss through evaporation, EST might have been different between RH treatments, influencing embryonic mortality and development. To eliminate the effect of EST, in the current study eggs were incubated at an EST of 37.8°C from embryonic d (E) 0 until E18 and at a high (55 to 60%) or low (30 to 35%) RH from E2 until hatch. Embryonic mortality, hatch curve, and several chick quality characteristics (length, weight, navel quality, organ weights, and DM of the yolk free body mass and yolk) were determined on E18 and at hatch. Low RH increased egg weight loss between E0 and E18 (+3.0%) and third week embryonic mortality (+3.0% of fertile eggs) and decreased hatch of fertile eggs (-2.9% of fertile eggs) compared with high RH. Hatch duration and chick quality characteristics did not differ between RH treatments. To assess the effect of RH during incubation on posthatch performance under suboptimal conditions, hatchlings were brooded at a normal (35.0°C at d 0, decreasing to 27.0°C at d 4) or cold (27.8°C at d 0, decreasing to 25.6°C at d 4) temperature until 4 d posthatch. Incubation RH and brooding temperature significantly interacted with posthatch growth but not development. Both low and high RH × cold brooding temperature resulted in lower (-6.9 and -6.0 g, respectively) BW than high RH × normal brooding temperature at 4 d of age. The cold brooding temperature resulted in lower daily feed intake (-1.3 g/chick) than the normal brooding temperature. In conclusion, incubating eggs at a low RH compared with a high RH and maintaining the EST at 37.8°C decreased hatch of fertile eggs, but had little effect on chick quality or posthatch performance.
We investigated the effects of an eggshell temperature (EST) of 35.6, 36.7, 37.8, and 38.9°C applied from d of incubation (E) 15, E17, and E19 on hatching pattern and embryonic organ development. A total of 2,850 first-grade eggs of a 43-week-old Ross 308 broiler breeder flock were incubated at an EST of 37.8°C until E15. From E15, E17, or E19 onward, eggs were incubated at an EST of 35.6, 36.7, 37.8, or 38.9°C. Moment of internal pipping (IP), external pipping (EP), and hatch was determined, and organ development was measured at E15, E17, E19, IP, EP, and hatch. A lower EST extended incubation duration compared to a higher EST. The lower incubation duration was mainly caused by the extended time until IP, whereas time between IP and hatch hardly varied between treatments. Relative heart weight was affected by EST already from 2 d after the start of EST treatment on E15, and effects became more pronounced at longer exposure time to various EST treatments. At hatch, the largest difference in relative heart weight was found between an EST of 35.6 and 38.9°C started at E15 (Δ=64.4%). From E17 onward, EST affected yolk-free body mass (YFBM) and relative stomach weight, where a lower EST resulted in a lower YFBM and relative stomach weight before IP and a higher YFBM and relative stomach weight after IP. From E19 onward, a lower EST resulted in a higher relative liver and spleen weight regardless of start time of treatment. Yolk weight and relative intestine weight were not affected by EST before and at E19, but a higher EST resulted in a higher yolk weight and lower relative intestine weight from IP onward. Based on the higher YFBM and higher relative organ growth found at hatch, we concluded that an EST lower than 37.8°C from E15 onward appears to be beneficial for optimal embryo development.
Leg problems in broiler chickens may partly be prevented by providing optimal circumstances for skeletal development during incubation. One of the factors demonstrated to affect bone development is eggshell temperature (EST), which provides a reliable reflection of embryo temperature. The present experiment aimed to investigate the effect of EST on development and asymmetry of the femur, tibia, and metatarsus in broiler chicken hatchlings. Eggs were incubated from d 0 until hatch at 1 of 4 EST: low (36.9°C), normal (37.8°C), high (38.6°C), and very high (39.4°C). At hatch, chick quality was determined in terms of chick length, yolk-free body mass, navel score, and organ weights. Tibia, femur, and metatarsus were weighed, their length and width (mediolateral diameter) and depth (craniocaudal diameter) at the middle of the shaft were measured, and their ash content was determined. Relative asymmetry of the leg bones was determined from their relative dimensions. Hatchability, chick quality, and organ development were lower for very high EST compared with all other treatments. Very high EST resulted in lowest tibia and metatarsus lengths (-3.1 to -8.4%) compared with all other treatments, and lower metatarsus weight (-9.1%) and femur length (-4.9%) compared with high EST. Relative asymmetry and ash content did not differ among treatments and no relation between EST and bone parameters was found. To conclude, very high EST resulted in lower bone development, hatchability, and chick quality. Few differences in bone development and chick quality were found between low, normal, and high EST.
During incubation, development of embryos is affected by eggshell temperature ( EST ). A constant EST of 37.8°C has been considered so far to result in most optimal embryo development. However, it can be hypothesized that a higher EST in week 2 in combination with a lower EST in week 3 stimulates embryo development and subsequent grow-out performance. In this study, 468 eggs of a 44-week-old Ross 308 breeder flock were incubated at different incubation temperature patterns in a 2 × 2 factorial arrangement. In week 2, EST was either 37.8°C or 38.9°C, and in week 3, EST was either 37.8°C or 36.7°C. At hatch, chick quality was determined. Thereafter, 320 broilers were grown in 32 pens (8 replicates/treatment) for 6 wk. Weekly BW and ADFI were determined, and at day 40, slaughter yield from 128 broilers (4 per pen) was determined. Results showed that EST in week 2 did not interact with EST in week 3 for any variable. An EST of 38.9°C in week 2 resulted in a 1 mm longer chick length ( P < 0.001) and 0.4 mmol/L lower blood glucose level ( P = 0.04) at hatch than an EST of 37.8°C. Grow-out performance was not affected by EST in week 2 of incubation. An EST of 36.7°C in week 3 resulted in a 1 mm shorter chick length ( P = 0.02), 1.0 mmol/L higher blood glucose level ( P < 0.001), and higher relative heart ( P = 0.01) and stomach weights ( P = 0.03) at hatch than an EST of 37.8°C. Additionally, an EST of 36.7°C in week 3 resulted in lower BW, ADG, and ADFI on slaughter age (all P < 0.03) than an EST of 37.8°C. In conclusion, no interaction between EST in week 2 and 3 of incubation was found for any variable. A higher EST in week 2 had minor effects at hatching and during rearing, whereas a lower EST in week 3 seemed to result in better organ development, but resulted in lower grow-out performance.
There are indications that lighting schedules applied during incubation can affect leg health at hatching and during rearing. The current experiment studied effects of lighting schedule: continuous light (24L), 12 hours of light, followed by 12 hours of darkness (12L:12D), or continuous darkness (24D) throughout incubation of broiler chicken eggs on the development and strength of leg bones, and the role of selected hormones in bone development. In the tibiatarsus and femur, growth and ossification during incubation and size and microstructure at day (D)0, D21, and D35 post hatching were measured. Plasma melatonin, growth hormone, and IGF-I were determined perinatally. Incidence of tibial dyschondroplasia, a leg pathology resulting from poor ossification at the bone’s epiphyseal plates, was determined at slaughter on D35. 24L resulted in lower embryonic ossification at embryonic day (E)13 and E14, and lower femur length, and lower tibiatarsus weight, length, cortical area, second moment of area around the minor axis, and mean cortical thickness at hatching on D0 compared to 12L:12D especially. Results were long term, with lower femur weight and tibiatarsus length, cortical and medullary area of the tibiatarsus, and second moment of area around the minor axis, and a higher incidence of tibial dyschondroplasia for 24L. Growth hormone at D0 was higher for 24D than for 12L:12D, with 24L intermediate, but plasma melatonin and IGF-I did not differ between treatments, and the role of plasma melatonin, IGF-I, and growth hormone in this process was therefore not clear. To conclude, in the current experiment, 24L during incubation of chicken eggs had a detrimental effect on embryonic leg bone development and later life leg bone strength compared to 24D and 12L:12D, while the light-dark rhythm of 12L:12D may have a stimulating effect on leg health.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.