BackgroundUnderstanding the effects of oxygen levels on yeast xylose metabolism would benefit ethanol production. In this work, xylose fermentative capacity of Scheffersomyces stipitis, Spathaspora passalidarum, Spathaspora arborariae and Candida tenuis was systematically compared under aerobic, oxygen-limited and anaerobic conditions.ResultsFermentative performances of the four yeasts were greatly influenced by oxygen availability. S. stipitis and S. passalidarum showed the highest ethanol yields (above 0.44 g g−1) under oxygen limitation. However, S. passalidarum produced 1.5 times more ethanol than S. stipitis under anaerobiosis. While C. tenuis showed the lowest xylose consumption rate and incapacity to produce ethanol, S. arborariae showed an intermediate fermentative performance among the yeasts. NAD(P)H xylose reductase (XR) activity in crude cell extracts correlated with xylose consumption rates and ethanol production.ConclusionsOverall, the present work demonstrates that the availability of oxygen influences the production of ethanol by yeasts and indicates that the NADH-dependent XR activity is a limiting step on the xylose metabolism. S. stipitis and S. passalidarum have the greatest potential for ethanol production from xylose. Both yeasts showed similar ethanol yields near theoretical under oxygen-limited condition. Besides that, S. passalidarum showed the best xylose consumption and ethanol production under anaerobiosis.

Industrial lignin such as kraft lignin is an abundant feedstock for renewable chemicals and materials. In this study, a process was developed for depolymerization of kraft lignin followed by an upgrading separation step and further bioconversion of the obtained monoaromatic compounds to muconic acid. First, industrial kraft lignin, Indulin AT, was processed into a guaiacol-rich stream using base-catalyzed depolymerization. This stream was subsequently upgraded using liquid–liquid extraction and evaporation to yield a more concentrated and less inhibitory stream, adapted for bioconversion. Finally, guaiacol was quantitatively converted to muconic acid through bioconversion using an engineered Pseudomonas putida strain containing cytochrome P450 and ferredoxin reductase for guaiacol assimilation and deletion of the native catBC genes for muconic acid production. Isomerization of muconic acid in a fermentation medium depending on pH was also studied.

Background Efficient xylose fermentation still demands knowledge regarding xylose catabolism. In this study, metabolic flux analysis (MFA) and metabolomics were used to improve our understanding of xylose metabolism. Thus, a stoichiometric model was constructed to simulate the intracellular carbon flux and used to validate the metabolome data collected within xylose catabolic pathways of non- Saccharomyces xylose utilizing yeasts. Results A metabolic flux model was constructed using xylose fermentation data from yeasts Scheffersomyces stipitis , Spathaspora arborariae , and Spathaspora passalidarum . In total, 39 intracellular metabolic reactions rates were utilized validating the measurements of 11 intracellular metabolites, acquired by mass spectrometry. Among them, 80% of total metabolites were confirmed with a correlation above 90% when compared to the stoichiometric model. Among the intracellular metabolites, fructose-6-phosphate, glucose-6-phosphate, ribulose-5-phosphate, and malate are validated in the three studied yeasts. However, the metabolites phosphoenolpyruvate and pyruvate could not be confirmed in any yeast. Finally, the three yeasts had the metabolic fluxes from xylose to ethanol compared. Xylose catabolism occurs at twice-higher flux rates in S. stipitis than S. passalidarum and S. arborariae . Besides, S. passalidarum present 1.5 times high flux rate in the xylose reductase reaction NADH-dependent than other two yeasts. Conclusions This study demonstrated a novel strategy for metabolome data validation and brought insights about naturally xylose-fermenting yeasts. S. stipitis and S. passalidarum showed respectively three and twice higher flux rates of XR with NADH cofactor, reducing the xylitol production when compared to S. arborariae . Besides then, the higher flux rates directed to pentose phosphate pathway (PPP) and glycolysis pathways resulted in better ethanol production in S. stipitis and S. passalidarum when compared to S. arborariae . Electronic supplementary material The online version of this article (10.1186/s12896-019-0548-0) contains supplementary material, which is available to authorized users.