No abstract

The objectives of this study are to examine the phosphorus release in aerobic sludge digestion and to better understand its governing mechanisms. In this study, phosphorus release was examined using the secondary sludge from both conventional and biological nutrient removal processes. The experiments were carried out at room temperature (22 ± 2°C), with or without automatic control of pH (4.5 to 7.8), and under three aeration schemes: fully aerobic (dissolved oxygen [DO] at 3 to 4 mg/L), low DO (0.2 to 0.8 mg/L), and cyclic (with alternate on/off aeration). The released phosphorus concentrations were 20 to 80 mg/L for the conventional sludge and 60 to 130 mg/L for the biophosphorus sludge. Higher phosphorus release also occurred at low pH (<6.0). As for the effect of DO, fully aerobic digestion caused higher phosphorus release than the low‐DO and cyclic operations. For better understanding, the solid phosphorus in sludge was conceptually categorized into three forms: inorganic phosphorus precipitates, organic cellular phosphorus, and polyphosphate (poly‐P) in polyphosphate‐accumulating organisms. Dissolution of inorganic phosphorus precipitates is controlled by physical and chemical conditions, with pH being the most important in this study. Lowering the pH to 4 to 6 clearly promoted the release of inorganic phosphorus. Polyphosphate hydrolysis, on the other hand, was found to be regulated biologically (sensitive to occurrence of anaerobic conditions) and was insignificant in the glutaraldehyde‐fixed sludge. Phosphorus release from organic phosphorus should correlate with the volatile solid (VS) digestion, which lyses the cells and frees the phosphorus covalently bonded with the organic matters. The amounts of phosphorus released per unit VS digested (ΔP/ΔVS) were therefore calculated for experiments with long periods of constant pH (to minimize interferences from dissolution/precipitation of inorganic phosphorus). The results suggested that some poly‐P was hydrolyzed and released accompanying the aerobic VS digestion, but at rates far lower than those under anaerobic conditions.

Low dissolved oxygen (DO) concentrations occur commonly in aerobic digesters treating thickened sludge, with benefits of smaller digester size, much reduced aeration cost, and higher digestion temperature (especially important for plants in colder areas). The effects of low DO concentrations on digestion kinetics were studied using the sludge from municipal wastewater treatment plants in Akron, Ohio, and Los Lunas, New Mexico. The experiments were conducted in both batch digestion and a mixed mode of continuous, fed-batch, and batch operations. The low DO condition was clearly advantageous in eliminating the need for pH control because of the simultaneous occurrence of nitrification and denitrification. However, when compared with fully aerobic (high DO) systems under constant pH control (rare in full-scale plants), low DO concentrations and a higher solids loading had a negative effect on the specific volatile solids (VS) digestion kinetics. Nonetheless, the overall (volumetric) digestion performance depends not only on the specific digestion kinetics, but also the solids concentration, pH, and digester temperature. All of the latter factors favor the low DO digestion of thickened sludge. The significant effect of temperature on low DO digestion was confirmed in the mixed-mode study with the Akron sludge. When compared with the well-known empirical correlation between VS reduction and the product (temperature 3 solids retention time), the experimental data followed the same trend, but were lower than the correlation predictions. The latter was attributed to the lower digestible VS in the Akron sludge, the slower digestion at low DO concentrations, or both. Through model simulation, the first-order decay constant (k d ) was estimated as 0.004 h 21 in the mixed-mode operations, much lower than those (0.011 to 0.029 h 21 ) obtained in batch digestion. The findings suggested that the interactions among sludges with different treatment ages may have a substantially negative effect on digestion kinetics. The use of multistage digesters, especially with small front-end reactors, may be advantageous in both ''process'' kinetics and ''biological reaction'' kinetics for sludge digestion. Water Environ. Res., 76, 453 (2004).

No abstract