Abstract:In laboratory, an underground coal gasification experiment has been conducted to examine the effect of different zone length of gasification to the composition of product gases. For that purpose two cylindris reactors which have different length are used. The length of first reactor is 80 cm and second reactor is 200 cm; both reactors has same diameter of 30cm. The gasification is conducted for 24 hours with the input air volume to the reactor is arranged at 70 liter/minute. The composition of gas produces from the first reactor is as follows: CO 2 = (11.6-14.4)%; C n H m = (0.0-0.4)%; CO = (1.2-6.8)%; O 2 = (3.2-7.2)%; H 2 = (0.8-3.2)%; C 3 H 8 = (0.0-0.9)%; CH 4 = (0.2-3.0)%. On the other hand, the second reactor produces gas with composition as follows: CO 2 = (5.0-15.0)%; C n H m = (0.0-0.3)%; CO = (1.8-4.0)%; O 2 = (4.0-13.8)%; H 2 = (0.2-4.0)%; C 3 H 8 = (0.0-1.2)%; CH 4 = (0.1-1.7)%. It is shown that the procentage of CO 2 ; CO; H 2 and CH 4 gas from the first reactor is higher than the second reactor. This result indicates that gasification reactions in the first reactor run better than the reactions occur in the second reactor. It is also supported by the calorific value of gas which is in the range of (127-517) kcal/m 3 for the gas from the first reactor compared with (118-460) kcal/m 3 for the gas from the second reactor. The different pattern of temperature T1 and T2 obtained from each reactor also supports this. Sari:Eksperimen gasifikasi batubara bawah yanah telah disimulasikan dilaboratorium. Eksperimen dilakukan dengan tujuan untuk menyelidiki pengaruh perbedaan panjang zona gasifikasi terhadap komposisi gas hasil. Untuk tujuan itu dua buah reaktor yang berbentuk silinder dengan panjang yang berbeda dipergunakan. Panjang reaktor pertama adalah 80 cm dan reaktor kedua adalah 200 cm; kedua reaktor mempunyai diameter yang sama yaitu 30 cm. Gasifikasi dilakukan selama 24 jam dengan volume udara yang ditiupkan masuk kedalam reaktor diatur sebesar 70 liter per menit. Hasil percobaan menunjukkan bahwa komposisi gas-gas yang dihasilkan dari reaktor pertama adalah sebagai berikut: CO 2 = (11,6-14,4)%; C n H m = (0,0-0,4)%; CO = (1,2-6,8)%; O 2 = (3,2-7,2)%; H 2 = (0,8-3,2)%; C 3 H 8 = (0,0-0,9)%; CH 4 = (0,2-3,0)%. Dilain pihak, reaktor kedua menghasilkan gas dengan komposisi: CO 2 = (5,0-15,0)%; C n H m = (0,0-0,3)%; CO = (1,8-4,0)%; O 2 = (4,0-13,8)%; H 2 = (0,2-4,0)%; C 3 H 8 = (0,0-1,2)%; CH 4 = (0,1-1,7)%. Hasil ini memperlihatkan bahwa prosentase gas CO 2 ; CO; H 2 dan CH 4 dari reaktor pertama lebih tinggi dibandingkan dengan reaktor kedua. Hasil tersebut mengindikasikan bahwa reaksi-reaksi gasifikasi yang terjadi pada reaktor pertama berjalan lebih baik baik dibandingkan dengan reaksi yang terjadi pada reaktor kedua. Hal ini juga didukung oleh nilai kalori gas yaitu berada dalam kisaran antara(127-517) kcal/m 3 untuk gas yang dihasilkan dari reaktor pertama dibandingkan dengan (118-460) kcal/m 3 untuk gas yang berasal dari reaktor kedua. Perbedaan pola temperatur T1 dan T2 dari masing-mas...
ABSTRAK Keunggulan dari keberadaan alur gasifikasi pada percobaan gasifikasi batubara bawah tanah diselidiki di laboratorium. Percobaan dilakukan dengan menggunakan sebuah reaktor simulasi berbentuk persegi panjang yang terbuat dari besi. Dalam studi ini ada dua percobaan yang dilakukan yaitu: percobaan pertama tanpa adanya alur gasifikasi dan percobaan kedua dengan sebuah alur gasifikasi didalam reaktor. Hasil percobaan menunjukkan bahwa jumlah gas CO 2 adalah dalam kisaran (4,6-11,4)% dan (11,6-14,4)%; gas CO dalam kisaran (0,3-4,0)% dan (1,2-6,8)%; gas H 2 dalam kisaran (0,1-2,5)% dan (1,6-3,2)%; gas C 3 H 8 dalam kisaran (0,0-0,6)% dan (0,2-0,9)%; gas CH 4 dalam kisaran (0,0-2,2)% dan (0,4-3,0)%, gas C n H m adalah dalam kisaran (0,0-0,0)% dan (0,0-0,4)% untuk percobaan pertama dan kedua berturut-turut. Nilai kalori gas adalah dalam kisaran (81-343)kcal/m 3 dan (263-516)kcal/m 3 berturut-turut. Kisaran dari pengembangan temperatur pada saat proses gasifikasi berjalan menunjukkan bahwa pada percobaan pertama, kisaran temperatur gasifikasi T 1 pada adalah (335-565) o C; dan T 2 adalah dalam kisaran (110-240) o C. Dilain pihak, T 1 untuk percobaan kedua adalah dalam kisaran (550-705) o C dan T 2 dalam kisaran (160-628) o C. Selain itu pada percobaan pertama, pola perubahan temperatur T 1 dan T 2 mempunyai kecenderungan menurun, sedangkan pada percobaan kedua, pola temperatur T 1 dan T 2 tersebut mempunyai kecenderungan meninggi seiring dengan jalannya proses gasifikasi. Hal ini dapat disimpulkan bahwa adanya alur gasifikasi pada percobaan kedua memungkinkan reaksi-reaksi gasifikasi berjalan lebih efisien dibandingkan dengan reaksi-reaksi yang terjadi pada percobaan pertama tanpa alur didalamnya.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
customersupport@researchsolutions.com
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.