The demand for vegetable proteins increases globally and seaweeds are considered novel and promising protein sources. However, the tough polysaccharide-rich cell walls and the abundance of polyphenols reduce the extractability and digestibility of seaweed proteins. Therefore, food grade, scalable, and environmentally friendly protein extraction techniques are required. To date, little work has been carried out on developing such methods taking into consideration the structural differences between seaweed species. In this work, three different protein extraction methods were applied to three Swedish seaweeds (Porphyra umbilicalis, Ulva lactuca, and Saccharina latissima). These methods included (I) a traditional method using sonication in water and subsequent ammonium sulfate-induced protein precipitation, (II) the pH-shift protein extraction method using alkaline protein solubilization followed by isoelectric precipitation, and (III) the accelerated solvent extraction (ASE®) method where proteins are extracted after pre-removal of lipids and phlorotannins. The highest protein yields were achieved using the pH-shift method applied to P. umbilicalis (22.6 ± 7.3%) and S. latissima (25.1 ± 0.9%). The traditional method resulted in the greatest protein yield when applied to U. lactuca (19.6 ± 0.8%). However, the protein concentration in the produced extracts was highest for all three species using the pH-shift method (71.0 ± 3.7%, 51.2 ± 2.1%, and 40.7 ± 0.5% for P. umbilicalis, U. lactuca, and S. latissima, respectively). In addition, the pH-shift method was found to concentrate the fatty acids in U. lactuca and S. latissima by 2.2 and 1.6 times, respectively. The pH-shift method can therefore be considered a promising strategy for producing seaweed protein ingredients for use in food and feed.

Ulva fenestrata is an economically and ecologically important green algal species with a large potential in seaweed aquaculture due to its high productivity, wide environmental tolerance, as well as interesting functional and nutritional properties. Here, we performed a series of manipulative cultivation experiments in order to investigate the effects of irradiance (50, 100, and 160 μmol photons m−2 s−1), temperature (13 and 18 °C), nitrate (< 5, 150, and 500 μM), phosphate (< 1 and 50 μM), and pCO2 (200, 400, and 2500 ppm) on the relative growth rate and biochemical composition (fatty acid, protein, phenolic, ash, and biochar content) in indoor tank cultivation of Swedish U. fenestrata. High irradiance and low temperature were optimal for the growth of this northern hemisphere U. fenestrata strain, but addition of nutrients or changes in pCO2 levels were not necessary to increase growth. Low irradiance resulted in the highest fatty acid, protein, and phenolic content, while low temperature had a negative effect on the fatty acid content but a positive effect on the protein content. Addition of nutrients (especially nitrate) increased the fatty acid, protein, and phenolic content. High nitrate levels decreased the total ash content of the seaweeds. The char content of the seaweeds did not change in response to any of the manipulated factors, and the only significant effect of changes in pCO2 was a negative relationship with phenolic content. We conclude that the optimal cultivation conditions for Swedish U. fenestrata are dependent on the desired biomass traits (biomass yield or biochemical composition).

Marine lipids contain a high proportion of polyunsaturated fatty acids (PUFA), including the characteristic long chain (LC) n-3 PUFA. Upon peroxidation these lipids generate reactive products, such as malondialdehyde (MDA), 4-hydroxy-2-hexenal (HHE) and 4-hydroxy-2-nonenal (HNE), which can form covalent adducts with biomolecules and thus are regarded as genotoxic and cytotoxic. PUFA peroxidation can occur both before and after ingestion. The aim of this study was to determine what levels of MDA, HHE and HNE can evolve in the gastric and intestinal lumen after ingesting meals containing fish or fish oil using a dynamic gastrointestinal (GI) model (TIM). The impact of the fish muscle matrix, lipid content, fish species, and oven baking on GI oxidation was evaluated. MDA and HHE concentrations in gastric lumen increased for all meals during digestion, with the highest level found with herring mince; ∼ 25 μM MDA and ∼ 850 nM HHE. Aldehyde concentrations reached in intestinal lumen during digestion of fish containing meals were generally lower than in gastric lumen, while isolated herring oils (bulk and emulsified) generated higher MDA and HHE values in intestinal lumen compared to gastric lumen. Based on aldehyde levels in gastric lumen, meals containing herring lipids were ranked: raw herring (17% lipid) = baked herring (4% lipid) > raw herring (4% lipid) ≫ herring oil emulsion > herring oil. Herring developed higher concentrations of MDA and HHE during gastric digestion compared to salmon, which initially contained lower levels of oxidation products. Cooked salmon generated higher MDA concentrations during digestion than raw salmon. Low levels of HNE were observed during digestion of all test meals, in accordance with the low content of n-6 PUFA in fish lipids.

In recent years, the interest in using seaweed for the sustainable production of commodities has been increasing as seaweeds contain many potentially worthwhile compounds. Thus, the extraction and refining processes of interesting compounds from seaweeds is a hot research topic but has been found to have problems with profitability for novel applications. To increase the economic potential of refining seaweed biomass, the content of the compounds of interest should be maximized, which can potentially be achieved through optimization of cultivation conditions. In this study, we studied how the monosaccharide composition of the green seaweed species Ulva fenestrata is influenced by the abiotic factors; irradiance, temperature, nitrate, phosphate, and pCO2. It was evident that lower nitrate concentration and cultivation at elevated temperature increased monosaccharide contents. A 70% increase in iduronic acid and a 26% increase in rhamnose content were seen under elevated irradiance and temperature conditions, though the absolute differences in monosaccharide concentration were small. Irradiance and nitrate impacted the ratio between iduronic and rhamnose, which is an indicator of the ulvan structure. These results could potentially be utilized to coax the ulvan towards specific bioactivities, and thus have a considerable impact on a potential biorefinery centered around Ulva.

Globally, there is a need for novel vegetarian protein sources. We recently showed that the pH-shift process, using alkaline protein solubilization followed by isoelectric precipitation, is an efficient way to produce extracts with high protein concentrations from Ulva lactuca (>50% on a dry matter basis). However, the total protein yield was low, and to improve this, the effects of adding ulvan lyase, preincubating the seaweed homogenate at pH 8.5 and using different protein extraction temperatures (8 °C, RT and 40 °C), were evaluated in this study. Addition of ulvan lyase reduced protein solubility but increased the precipitation. Incubation at pH 8.5, without ulvan lyase added, significantly increased both protein solubility and precipitation at 8 °C and RT. Temperature per se had no effect on protein solubility, while protein precipitation increased with decreasing temperature. Highest protein yield (29%) was achieved when keeping the process at 8 °C with a preincubation step at pH 8.5 for 1 h. By these process modifications, the yield was 3.2 times higher than achieved by the control process (9.2%).