This study explored the potential value of in-line composite somatic cell count (ISCC) sensing as a sole criterion or in combination with quarter-based electrical conductivity (EC) of milk, for automatic detection of clinical mastitis (CM) during automatic milking. Data generated from a New Zealand research herd of about 200 cows milked by 2 automatic milking systems during the 2006-2007 milking season included EC, ISCC, monthly laboratory-determined SCC, and observed cases of CM that were treated with antibiotics. Milk samples for ISCC and laboratory-determined SCC were taken sequentially at the end of a cow milking. Both samples were derived from a composite cow milking obtained from the bottom of the milk receiver. Different time windows were defined in which true-positive, false-negative, and false-positive alerts were determined. Quarters suspected of having CM were visually checked and, if CM was confirmed, sampled for bacteriological culturing and treated with an antibiotic treatment. These treated quarters were considered as gold-standard positives for comparing CM detection models. Alert thresholds were adjusted to achieve a sensitivity of 80% in 3 detection models: using ISCC alone, EC alone, or a combination of these. The success rate (also known as the positive predictive value) and the false alert rate (number of false-positive alerts per 1,000 cow milkings) were used to evaluate detection performance. Normalized ISCC estimates were highly correlated with normalized laboratory-determined SCC measurements (r = 0.82) for SCC measurements >200 x 10(3) cells/mL. Using EC alone as a detection tool resulted in a range of 6.9 to 11.0% for success rate, and a range of 4.7 to 7.8 for the false alert rate. Values for the ISCC model were better than the model using EC alone with 12.7 to 15.6% for the success rate and 2.9 to 3.7 for the false alert rate. Combining sensor information to detect CM, by using a fuzzy logic algorithm, produced a 2- to 3-fold increase in the success rate (range 21.9 to 32.0%) and a 2- to 3-fold decrease in the false alert rate (range 1.2 to 2.1) compared with the models using ISCC or EC alone. Results suggest that the performance of a CM detection system improved when ISCC information was added to a detection model using EC information.

Machine milking induced repeatable, short-term changes in thickness of the teat apex. These changes were measured with a spring-loaded caliper instrument under milking conditions that imposed differing forces on the teat apex. The mean percentage changes in teat end thickness (relative to the premilking values for individual teats) varied from 10% decrease up to 20% or more increase depending on the particular milking system used. The overall decrease in teat end thickness associated with cannula milking, milking at very low vacuum levels or milking with positive pressure pulsation may result from: (i) decrease in the intramammary pressure; and/or (ii) small changes in tone of teat musculature; and/or (iii) changes in the distribution of interstitial fluids in the teat apex. The overall increase in teat thickness caused by conventional or PKME milking systems results mainly from oedema (the extravascular accumulation of fluid). It is likely that milking equipment can, and should, be designed to minimize circulatory impairment resulting in oedema of the teat.Small changes in thickness of the teat apex were measured reliably and repeatably with a spring-loaded caliper instrument known as a cutimeter (Hamann, 1987;). Subsequently, this instrument was modified to provide a constant load to the teat independent of the initial diam. and to measure changes in thickness of the teat apex in response to changes in the load applied. The repeatability of measurements obtained with this modified caliper instrument was excellent over the whole pressure range, the coefficient of variation being about 2 % at low (1-2 kPa), medium (5-7 kPa) or high (10 kPa or more) levels of pressure applied to the teat (Hamann et al. 1988).The paper describes four studies, in the research herd at Kiel, designed to measure the changes in teat end thickness under a range of milking conditions and to determine the cause of the changes.

Four strategies for selecting cows for intramammary therapy with benzathine cloxacillin at drying off were compared in 12 Victorian dairy herds. The bacteriological status of all quarters of all (1044) cows was determined just before drying off, within 2 d of calving, and again 3 to 5 months after calving. All cases of clinical mastitis (from calving to mid-lactation) were recorded. Cows not infected at drying off were allocated randomly to 2 subgroups of approximately 350 cows each: not infected, not treated (NI-NT), or not infected, all quarters treated (NI-AT). New infection rates in the dry period (3.8% for NI-NT vs 2.1% for NI-AT) and in early lactation (4.1% for NI-NT vs 3.9% for NI-AT) were low and these differences were not significant. Incidence of clinical mastitis in early lactation was almost 50% higher for the treated group of uninfected cows compared with the untreated group (0.05 less than p less than 0.1). Cows infected in one or more quarters at drying off were split randomly into 2 subgroups of approximately 170 cows each: infected, all quarters treated (I-AT), or infected quarters treated only (I-QT). The new infection rate during the dry period was nearly 4 times higher for I-QT (15.3%) due to significantly more new infections by Staphylococcus aureus and Streptococcus uberis.(ABSTRACT TRUNCATED AT 250 WORDS)

Machine-induced changes in diameter, thickness, and compressibility of the teat apex and teat barrel were measured on all teats of four cows milked at vacuums of 25, 30, 40, and 50 kPa. Measurements were made with an electronic caliper instrument immediately before milking and then at .5, 15, and 30 min after milking. Teat length was also measured at these times. Immediately after milking, for the two higher levels, teats were significantly thicker (7 to 10% thicker at 40 kPa, 17 to 25% at 50 kPa), shorter (by 3 to 6 mm), smaller in diameter (by 2 to 4 mm for the apex, 3 to 6 mm for the barrel), and less compressible for all milking treatments compared with the premilking status for individual teats. Although teat thickness recovered to the premilking mean values 30 min after milking at 40 or 50 kPa, the barrel still was significantly thicker after 30 min compared with those at the lower vacuum treatments. We suggest that changes in teat length, diameter, thickness, and compressibility after milking at low vacuum levels mainly reflect tissue responses to udder evacuation. In contrast, increased teat wall thickness and reduced compressibility of teat tissue at higher vacuum levels likely result mainly from machine-induced edema.

The effects of three selection strategies for dry cow therapy on prevention of new infections and rate of antibiotic usage were compared. Quarter infection status of 1044 cows in 12 herds was determined by bacteriological methods at drying off, calving and three to five months into the following lactation. Cows that were uninfected at drying off were randomly allocated to treatment (whole udder, dry cow therapy) and non-treatment groups. Infected cows were randomly allocated to whole udder or infected quarter only treatments. The strategies compared were blanket treatment (treat all quarters of all cows), selective cow treatment (treat all quarters of any cow infected in one or more quarters) and selective quarter treatment (treat infected quarters only). Selective cow treatment was identified as the preferred strategy. Blanket treatment resulted in increased antibiotic usage (15.5 vs 6.4 tubes per infection eliminated) with no additional benefit, and selective quarter treatment resulted in a higher new infection rate (6.4% vs 3.9% quarters) in the dry period. The prevalence of infection within a herd at drying off had no influence on new infection rates in the dry period or early lactation. The cure rate after dry cow treatment (mean of 66%) decreased significantly with increasing age (P < 0.001). Cows infected in the previous lactation contributed over 76% of infections at calving and nearly 70% at mid-lactation. To lower the incidence of mastitis in a herd, a greater emphasis on culling of older infected cows and prevention of new infections during lactation is needed.