The conjugation of monomethyl auristatin E (MMAE) to trastuzumab using a reduction bis-alkylation approach that is capable of rebridging reduced (native) antibody interchain disulfide bonds has been previously shown to produce a homogeneous and stable conjugate with a drug-to-antibody ratio (DAR) of 4 as the major product. Here, we further investigate the potency of the DAR 4 conjugates prepared by bis-alkylation by comparing to lower drug loaded variants to maleimide linker based conjugates possessing typical mixed DAR profiles. Serum stability, HER2 receptor binding, internalization, in vitro potency, and in vivo efficacy were all evaluated. Greater stability compared with maleimide conjugation was observed with no significant decrease in receptor/FcRn binding. A clear dose-response was obtained based on drug loading (DAR) with the DAR 4 conjugate showing the highest potency in vitro and a much higher efficacy in vivo compared with the lower DAR conjugates. Finally, the DAR 4 conjugate demonstrated superior efficacy compared to trastuzumab-DM1 (T-DM1, Kadcyla), as evaluated in a low HER2 expressing JIMT-1 xenograft model.

The efficacy of protein-based medicines can be compromised by their rapid clearance from the blood circulatory system. Achieving optimal pharmacokinetics is a key requirement for the successful development of safe protein-based medicines. Protein PEGylation is a clinically proven strategy to increase the circulation half-life of protein-based medicines. One limitation of PEGylation is that there are few strategies that achieve site-specific conjugation of PEG to the protein. Here, we describe the covalent conjugation of PEG site-specifically to a polyhistidine tag (His-tag) on a protein. His-tag site-specific PEGylation was achieved with a domain antibody (dAb) that had a 6-histidine His-tag on the C-terminus (dAb-His(6)) and interferon α-2a (IFN) that had an 8-histidine His-tag on the N-terminus (His(8)-IFN). The site of PEGylation at the His-tag for both dAb-His(6)-PEG and PEG-His(8)-IFN was confirmed by digestion, chromatographic, and mass-spectral studies. A methionine was also inserted directly after the N-terminal His-tag in IFN to give His(8)Met-IFN. Cyanogen bromide digestion studies of PEG-His(8)Met-IFN were also consistent with PEGylation at the His-tag. By using increased stoichiometries of the PEGylation reagent, it was possible to conjugate two separate PEG molecules to the His-tag of both the dAb and IFN proteins. Stability studies followed by in vitro evaluation confirmed that these PEGylated proteins retained their biological activity. In vivo PK studies showed that all of the His-tag PEGylated samples displayed extended circulation half-lives. Together, our results indicate that site-specific, covalent PEG conjugation at a His-tag can be achieved and biological activity maintained with therapeutically relevant proteins.

Autocatalytic cleavage of lithostathine leads to the formation of quadruple-helical fibrils (QHF-litho) that are present in Alzheimer's disease. Here we show that such fibrils also occur in Creutzfeldt-Jakob and Gerstmann-Strä ussler-Scheinker diseases, where they form protease-K-resistant deposits and co-localize with amyloid plaques formed from prion protein. Lithostathine does not appear to change its native-like, globular structure during fibril formation. However, we obtained evidence that a cluster of six conserved tryptophans, positioned around a surface loop, could act as a mobile structural element that can be swapped between adjacent protein molecules, thereby enabling the formation of higher order fibril bundles. Despite their association with these clinical amyloid deposits, QHF-litho differ from typical amyloid fibrils in several ways, for example they produce a different infrared spectrum and cannot bind Congo Red, suggesting that they may not represent amyloid structures themselves. Instead, we suggest that lithostathine constitutes a novel component decorating disease-associated amyloid fibrils. Interestingly, [6,6 ]bibenzothiazolyl-2,2 -diamine, an agent found previously to disrupt aggregates of huntingtin associated with Huntington's disease, can dissociate lithostathine bundles into individual protofilaments. Disrupting QHF-litho fibrils could therefore represent a novel therapeutic strategy to combat clinical amyloidoses.

Neurodegenerative diseases are characterized by the presence of filamentous aggregates of proteins. We previously established that lithostathine is a protein overexpressed in the pre‐clinical stages of Alzheimer's disease. Furthermore, it is present in the pathognomonic lesions associated with Alzheimer's disease. After self‐proteolysis, the N‐terminally truncated form of lithostathine leads to the formation of fibrillar aggregates. Here we observed using atomic force microscopy that these aggregates consisted of a network of protofibrils, each of which had a twisted appearance. Electron microscopy and image analysis showed that this twisted protofibril has a quadruple helical structure. Three‐dimensional X‐ray structural data and the results of biochemical experiments showed that when forming a protofibril, lithostathine was first assembled via lateral hydrophobic interactions into a tetramer. Each tetramer then linked up with another tetramer as the result of longitudinal electrostatic interactions. All these results were used to build a structural model for the lithostathine protofibril called the quadruple‐helical filament (QHF‐litho). In conclusion, lithostathine strongly resembles the prion protein in its dramatic proteolysis and amyloid proteins in its ability to form fibrils.

Site-selective conjugation generally requires both (i) molecular engineering of the protein of interest to introduce a conjugation site at a defined location and (ii) a site-specific conjugation technology.