Six snack-type bars were manufactured, to contain oat and wheat germ and two different walnut levels, agglutinated with natural sweeteners and fats. Two bars also contained toasted amaranth with brown sugar cover and wheat extrudate, while two others, contained puffed instead of toasted amaranth. Water activity (Aw) and moisture were determined in the manufactured products. Quality and sensory evaluation and proximate analysis were carried out on the bars containing highest levels of walnuts (18%). The caloric contribution of the bars was computed by Atwater methods. The nutritional quality of the bars was determined by means of the Protein Efficiency Ratio (PER) and Net Protein Ratio (NPR), and the results were used to obtain relative PER and relative NPR. Samples of the latter bars were kept under accelerated storage for 15 days at 37 degrees C and analyzed every 5 days to determine their Aw, moisture, peroxide and sensory acceptability. The drying time for the cereal - and walnut - based bars was 45 min at 120 degrees C. All bars presented a good fiber supply and the CN1 bar, containing only oat, wheat germ and walnut, had the greatest protein content. In the sensory evaluation, the walnut level with the greatest preference was 18%. PER and NPR values of the bars did not differ significantly showing values approximately 86% that of the casein value. During storage, the moisture and Aw decreased in all the bars. Peroxides remained within the acceptable ranges; acceptability based on sensory evaluation remained best in the bar with toasted amaranth.(ABSTRACT TRUNCATED AT 250 WORDS)
The effect of processing on chemical composition and protein quality of three legumes was studied. The species analyzed were beans (Phaseolus vulgaris), Tórtola and Coscorrón varieties; lentils (Lens esculenta), Laird variety; and chick peas (Cicer arietinum), California-INIA variety. The legumes were soaked in a solution of Na2 EDTA at 0.03% for 16 h and cooked for a predetermined period for each species. They were dried in a tray drier with cross currents of air flowing at a speed of 10 m/min until the residual moisture content was 8%. The water activity in the resulting products ranged from 0.574 to 0.587, thus completely assuring no microbial activity. No important changes were observed in the legumes protein, fat, or fibre contents after processing. The soaking solution was effective in reducing the phytic acid content from 2.99 to 1.64 mg/100 g in the Tórtola beans, which had the highest acid value prior processing. In all the species the heat treatment reduced the activity of the trypsin inhibitors by at least 50%. Cooking and drying significantly increased protein digestibility in all the legumes studied, with chick peas showing the most dramatic increase: form 54.7% pre-processing to 94.9% post-processing. With regard to Net Protein Ratio (NPR), chick peas had a value of 4.03, followed by Tórtola beans (3.29), Coscorrón (3.09) and lentils (2.61). The NPR value for the casein diet was 4.20.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.