Chicken manure and pig fat are found abundantly around the globe, and there is a challenge to get rid of them. This waste has considerable energy potential to be recovered into fuel, but extracting this energy from some by-products, especially fat, isn’t an easy task. When anaerobic digestion technology stepped to the level of anaerobic co-digestion, the utilisation of hardly degradable waste became feasible. Our research was conducted on anaerobic co-digestion of chicken manure as the primary substrate with pig fat as a fat reach supplement in a semi-continuous mode at different organic load rates. The influence of fat waste on the process of biogas production from chicken manure and the composition of the obtained products was determined using an organic load rate of 3.0–4.5 kg VS·(m3·day)−1. A sturdy and continuously growing biogas production was observed at all organic load rates, implying the synergetic effect on chicken manure and pig fat co-digestion. The highest specific methane yield, 441.3 ± 7.6 L·kg VS−1, was observed at an organic load rate of 4.5 kg VS·(m3·day)−1. The research results showed that co-digestion of chicken manure with pig fat is an appropriate measure for fat utilisation and contributes to the increase in biogas yield, methane concentration, and overall methane yield at investigated organic load rates.

Manure is considered a by-product or organic waste in cattle, pig, chicken or other animal breeding farms, which can be a valuable product as compost or feedstock for biogas production. The production of biomethane from biogas always copes with the formation of carbon dioxide (CO2) as a by-product. This CO2 may be recycled through the feedstock as a pretreatment to maximize homogeneity, and improve biogas yield and biogas quality. The CO2-pretreatment process of cow manure (CoM), chicken manure (ChM) and pig manure (PM) was performed in the continuously fed agitated reactor at 25 °C temperature and ambient barometric pressure. Biogas yield and composition exploration were performed in an anaerobic continuous feeding digester with controlled mesophilic (37 °C) environmental conditions. The CO2 pretreated PM, CoM and ChM yielded 234.62 ± 10.93 L/kgVS, 82.01 ± 3.19 L/kgVS and 374.53 ± 9.27 L/kgVS biomethane from feedstock volatile solids, respectively. The biomethane yield from CO2 pretreated CoM, ChM and PM achieved was higher over untreated manure by +33.78%, +28.76% and +21.78%, respectively. The anaerobic digestion process of tested feedstocks was stable, and the pH of the substrate was kept steady at a pH of CoM 7.77 ± 0.02, PM 8.07 ± 0.02 and ChM 8.09 ± 0.02 during all the experiment. The oxidation-reduction potential after pretreatment was within the optimal range (−255 ± 39.0 to −391 ± 16.8 mV) for anaerobic digestion. This process also had a positive effect on the energy generated from the feedstock, with ChM showing the greatest increase, from 2.38 MJ/kg to 3.06 MJ/kg.

Biogas production from manure and other organic matter, or combinations thereof, is part of the circular economy, and the use of the digestate from biogas production for plant nutrition and thus for soil fertility restoration and organic carbon (C) sequestration completes the circular economy cycle. The use of digestate from biogas production in agriculture is one of the sustainable ways to manage manure or organic waste, an alternative to conventional chemical fertilizers, and a means to achieve the objectives of the European Green Deal. To this end, two two-factor pot experiments were carried out in 2019–2020. Factor A—1. Control (without fertilization), 2. Liquid cow manure 170 kg ha−1 N (N170), 3. Digested manure 170 kg ha−1 N (N170), 4. Digested manure 140 kg ha−1 N (N140), 5. Digested manure 110 kg ha−1 N (N110); Factor B—1. Plants not cultivated, 2. Plants cultivated. The experiments determined the effect of digestate on the changes in soil nitrate (NO3-N), ammonium (NH4-N) and mineral (NO3-N + NH4-N) nitrogen, and available phosphorus (P2O5) and potassium (K2O) in the soil without plants as well as with plants cultivated and evaluated the risk of migration of macronutrients into deeper soil layers. The results showed that the application of the highest allowed rates under the Nitrates Directive (N170) and N140 digestate is accompanied by the addition of high levels of ammonium (NH4-N) nitrogen, which alters the balance of ammonium (NH4-N) and nitrate (NO3-N) nitrogen in the soil, and the extent of their migration to the deeper layers. These results suggest that the application of digestate to agricultural land enhances the migration of nitrogen and, in phosphorus-rich soils, of phosphorus (PO4-P) compounds to deeper layers (>25 cm). In order to achieve environmental objectives, digestate rates should be based on the agrochemical properties of the soil and the needs of the plants and should not exceed 65% of the nitrogen needed by the plants from mineral fertilizers.