No abstract

A protein purification procedure is required to obtain high-value recombinant injectable vaccine proteins produced in plants as a bioreactor. However, existing purification procedures for plant-derived recombinant proteins are often not optimized and are inefficient, with low recovery rates. In our previous study, we used 25–30% ammonium sulfate to precipitate total soluble proteins (TSPs) in purification process for recombinant proteins from plant leaf biomass which has not been optimized. Thus, the objective in this study is to optimize the conditions for plant-derived protein purification procedures. Various ammonium sulfate concentrations (15–80%) were compared to determine their effects on TSPs yield. With 50% ammonium sulfate, the yield of precipitated TSP was the highest, and that of the plant-derived colorectal cancer-specific surface glycoprotein GA733 fused to the Fc fragment of human IgG tagged with endoplasmic reticulum retention signal KDEL (GA733P-FcK) protein significantly increased 1.8-fold. SDS-PAGE analysis showed that the purity of GA733P-FcK protein band appeared to be similar to that of an equal dose of mammalian-derived GA733-Fc (GA733M-Fc). The binding activity of purified GA733P-FcK to anti-GA733 mAb was as efficient as the native GA733M-Fc. Thus, the purification process was effectively optimized for obtaining a high yield of plant-derived antigenic protein with good quality. In conclusion, the purification recovery rate of large quantities of recombinant protein from plant expression systems can be enhanced via optimization of ammonium sulfate concentration during downstream processes, thereby offering a promising solution for production of recombinant GA733-Fc protein in plants.

Silkworm pupae have much potential and many applications as a natural medicine to promote human health. However, their chemical components have not been fully characterized or understood. HPLC analysis was conducted to determine the content ratio (%) of individual amino acids in total protein of the pupae. It showed that glutamic acid (18.3%), histidine (14.6%) and alanine (10.2%) are the most common amino acids in silkworm pupae. Fatty acid composition of silkworm pupae oil was revealed by high‐pressure liquid chromatography and gas chromatography – mass spectroscopy analyses. They contain a high ratio of essential fatty acids, [α‐linolenic acid (ω‐3 fatty acid]+ linoleic acid) (49.0%), and also contain non‐essential fatty acids, oleic acid (19.9%), palmitoleic acid (2.5%), palmitic acid (19.7%), stearic acid (8.6%), and eicosapentaenoic acid (EPA) (0.3%). In addition, they also contain antioxidants, quercetin diglucoside and nutritionally important riboflavin (vitamin B2). This study suggests that silkworm pupae are a nutritionally valuable food product and are applicable as cosmetic components with essential amino acids, essential fatty acids, antioxidants and vitamins. The animal experiment showed that alcohol dehydrogenase (ADH) activity was significantly higher in the liver of mice orally administered with 0.5 mg/mL of silkworm extract and alcohol than with commercial Dawn808™ and alcohol, indicating that silkworm pupae extracts have alcohol detoxification activity.

The expression and glycosylation patterns of anti-colorectal cancer therapeutic monoclonal antibody (mAb) CO17-1A recognizing the tumor-associated antigen GA733-2, expressed in human colorectal carcinoma cells, were observed in the leaf and stem tissues of primary (0 cycle), secondary (1 cycle), and tertiary (2 cycle) growths of seedlings obtained from the stem cut of T2 plants. The bottom portion of the stem of T2 seedlings was cut to induce the 1 cycle shoot growth, which was again cut to induce the 2 cycle shoot growth. In the 1 and 2 cycle growths, the periods for floral organ formation (35 days) was shorter than that (100 days) for the 0 cycle growth. The genes of heavy and light chains of mAb CO17-1A existed at the top, middle, and basal portions of the leaves and stem obtained from the 0, 1, and 2 cycle plants. The protein levels in the leaves and stem tissues from the 1 and 2 cycles were similar to those in the tissues from the 0 cycle. The glycosylation level and pattern in the leaf and stem did not alter dramatically over the different cycles. Surface plasmon resonance (SPR) confirmed that mAbs CO17-1A obtained from leaf and stem tissues of the 0, 1, and 2 cycles had similar binding affinity for the GA733-2 antigen. These data suggest that the shoot growth by bottom stem cutting is applicable to speed up the growth of plant biomass expressing anti-colorectal cancer mAb without variation of expression, glycosylation, and functionality.

The baculovirus-insect cell expression system has been used to produce functional recombinant proteins. The antigen GA733 is a cell-surface glycoprotein highly expressed on most human colorectal carcinoma cells. Conditions for the expression of GA733 fused to the human immunoglobulin IgG Fc fragment (GA733-Fc) were optimized in the baculovirus expression system. Several variable factors were adjusted to optimize expression, including the cell line (Sf9 and High Five), multiplicity of infection (MOI) value (0.05, 0.1, 0.5, 1 and 3), post-infection time (48, 72 and 96 h) and harvested sample (cell culture media (CM) or cell lysate (CL)). In addition, two pFastBac Dual vectors carrying the GA733-Fc gene were constructed to express GA733-Fc with or without an endoplasmic reticulum (ER) retention sequence KDEL and used to generate recombinant baculoviruses. Western blot showed that expression depended on the conditions used to express the recombinant proteins. The protein production level and secretion capability differed in each cell line. In Sf9 cells, the highest expression in the CM and CL was obtained with GA733-Fc at 96 h post-infection at 0.1 MOI and with GA733-FcK at 96 h post-infection at 3 MOI, respectively. In High Five cells, the highest expression in the CM and CL was obtained with GA733-Fc at 48 h post-infection at 1 MOI and with GA733-FcK at 48 h post-infection at 3 MOI, respectively. These results suggest that the MOI value, post-infection time and subcellular localization affect expression, and that these conditions can be modified to optimize protein expression in the baculovirus-insect cell system.