The development of new organic semiconductors with improved electrical performance and enhanced environmental stability is the focus of considerable research activity. This paper presents the design, synthesis, optical and electrochemical characterization, crystal packing, modeling and thin film morphology, and organic thin film field effect transistor (OTFT) device data analysis for a novel 2,6-bis[2-(4-pentylphenyl)vinyl]anthracene (DPPVAnt) organic semiconductor. We observed a hole mobility of up to 1.28 cm2/V.s and on/off current ratios greater than 107 for OTFTs fabricated using DPPVAnt as an active semiconductor layer. The mobility value is comparable to that of the current best p-type semiconductor pentacene-based device performance. In addition, we found a very interesting relationship between the charge mobility and molecule crystal packing in addition to the thin film orientation and morphology of the semiconductor as determined from single-crystal molecule packing study, thin film X-ray diffraction, and AFM measurements. The high performance of the semiconductor ranks among the best performing p-type organic semiconductors reported so far and will be a very good candidate for applications in organic electronic devices.
The electrical performance of organic thin-film transistors (TFTs) often degrades when the devices are exposed to air. This is generally ascribed to the generation of trap states, [1] possibly as a result of the oxidation of the organic semiconductor.[2] One strategy to improve the stability of p-channel organic TFTs is the synthesis of conjugated semiconductors with a relatively large ionization potential. [3][4][5][6][7][8] However, most of the TFTs based on organic semiconductors with large ionization potentials reported up till now have shown carrier mobilities that are smaller than that of pentacene. Here, we report on a new organic semiconductor, di(phenylvinyl)anthracene (DPVAnt), [9] that combines large carrier mobility (similar to that of pentacene) with increased ionization potential and improved stability as compared to pentacene. DPVAnt has been synthesized by a Suzuki coupling reaction between 2,6-dibromoanthracene and 4,4,5,5-tetramethyl-2-[2-phenylvinyl]-[1,3,2]dioxaborolane [9] with a yield of 85%.Pentacene has been purchased from Fluka. Both semiconductors have been purified by temperature gradient sublimation in a stream of inert gas. Cyclic voltammetry indicates a highest occupied molecular orbital (HOMO) energy of -5.4 eV for DPVAnt, as compared to -5.0 eV for pentacene. From UV-vis absorption spectroscopy we have determined an optical bandgap of 2.6 eV for DPVAnt and 1.8 eV for pentacene. These results are consistent with the general observation that molecules characterized by a smaller conjugated p-system have more negative HOMO energies and larger bandgaps.Simple TFT test structures have been prepared on heavily doped silicon substrates (serving as the gate electrode) with a thermally grown SiO 2 gate dielectric. The dielectric surface has been treated with octadecyltrichlorosilane (OTS), [10] and the organic semiconductor has been vacuum deposited onto the substrate. Gold source/drain contacts have been thermally evaporated through a shadow mask (Fig. 1a). During the deposition of the semiconductor, the substrates are held at a temperature of 60°C for pentacene and 80°C for DPVAnt. The carrier mobilities extracted from the transfer characteristics measured in air are 1 cm 2 V -1 s -1 for pentacene and 1.3 cm 2 V -1 s -1 for DPVAnt (Fig. 1b). Both TFTs have an on/off current ratio of 10 7 and a subthreshold swing of 500 mV decade -1. Perhaps the most striking differences between the two devices are the much more negative turn-on and threshold voltages of the DPVAnt transistor (V turn-on = -14 V, V th = -16 V) as compared to the pentacene TFT (V turn-on = -2 V, V th = -5 V). The exact reason for this difference is not known, but it may be related to the more negative HOMO energy of DPVAnt as compared to pentacene. As shown by the atomic force microscopy (AFM) images in Figure 1c and d, both semiconductors form well-ordered polycrystalline films, which is a prerequisite for obtaining large carrier mobilities.For practical applications, a transistor structure with patterned gate electrodes ...
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
customersupport@researchsolutions.com
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.