A growth performance and carcass evaluation study was conducted to determine the maximal inclusion rate of corn distillers dried grain with solubles (DDGS) in grower-finisher pig diets when formulated on a total AA basis. A total of 240 (28.4 +/- 0.8 kg of BW) crossbred pigs [(Yorkshire x Landrace) x Duroc] were allotted randomly within sex and weight outcome groups to 1 of 24 pens. Pens were assigned randomly within the initial BW groups to 1 of 4 dietary treatment sequences in a 5-phase grower-finisher feeding program in a 4 x 3 factorial arrangement of treatments. The inclusion level of DDGS (0, 10, 20, or 30%) in the diet and the initial BW class [low (23.2 kg), medium (28.1 kg), or high (33.8 kg)] served as the main factors for the grower-finisher performance study. All diets were formulated to contain similar concentrations of total Lys, ME, calcium, and phosphorus within each phase. Pigs were slaughtered and carcass data were collected when the average BW of pigs in a pen reached 114 +/- 2.25 kg. Dietary treatment and initial weight groups did not interact for any response variables, and only the main effects of dietary treatment are presented. Pigs fed the 20 or 30% DDGS diets had reduced ADG (P < 0.05) compared with that of the 0 or 10% DDGS groups, but ADFI was unaffected by dietary treatment. Gain:feed decreased when pigs were fed 30% DDGS (P < 0.05) compared with the 0, 10, and 20% DDGS dietary inclusion levels. Loin depth was lower in pigs fed the 30% DDGS diets (P < 0.05), but backfat depth and percentage of carcass lean did not differ among treatments. Iodine number of carcass fat increased linearly (P < 0.01) with increasing dietary DDGS concentration, and belly firmness adjusted for belly thickness was reduced (P < 0.05) for pigs fed the 30% DDGS diets compared with pigs fed the 0 or 20% DDGS diets. Color measurements, ultimate pH, and visual evaluations (color, firmness, and marbling scores) of the LM did not differ among treatments. Cooking loss, 24-h drip loss, and total moisture loss were not affected by DDGS in the diets. However, differences were detected between 0 and 20% DDGS treatments for 11-d purge loss (P < 0.05). Dietary treatment did not affect Warner-Bratzler shear force of cooked loin chops. Results from this study indicate that when diets for grower-finisher pigs are formulated on a total AA basis, less than 20% DDGS should be included in the diet for optimal performance and carcass composition. Feeding DDGS in swine finishing diets did not have any detrimental effects on pork muscle quality.

The objectives of this study were to define a beef carcass population in terms of muscle color, ultimate pH, and electrical impedance; to determine the relationships among color, pH, and impedance and with other carcasses characteristics; and to determine the effect of packing plant, breed type, and sex class on these variables. One thousand beef carcasses were selected at three packing plants to match the breed type, sex class, marbling score, dark-cutting discount, overall maturity, carcass weight, and yield grade distributions reported for the U.S. beef carcass population by the 1995 National Beef Quality Audit. Data collected on these carcasses included USDA quality and yield grade data and measurements of muscle color (L*, a*, b*), muscle pH, and electrical impedance of the longissimus muscle. About one-half (53.1%) of the carcasses fell within a muscle pH range of 5.40 to 5.49, and 81.3% of the carcasses fell within a longissimus muscle pH range of 5.40 to 5.59. A longissimus muscle pH of 5.87 was the approximate cut-off between normal and dark-cutting carcasses. Frequency distributions indicated that L* values were normally distributed, whereas a* and b* values were abnormally distributed (skewed because of a longer tail for lower values, a tail corresponding with dark-cutting carcasses). Electrical impedance was highly variable among carcasses but was not highly related to any other variable measured. Color measurements (L*, a*, b*) were correlated (P < 0.05) with lean maturity score (-.58, -.31, and -.43, respectively) and with muscle pH (-.40, -.58, and -.56, respectively). In addition, fat thickness was correlated with muscle pH and color (P < 0.05). There was a threshold at approximately .76 cm fat thickness, below which carcasses had higher muscle pH values and lower colorimeter readings. Steer carcasses (L* = 39.62, a* = 25.20, and b* = 11.03) had slightly higher colorimeter readings (P < 0.05) than heifer carcasses (L* = 39.20, a* = 24.78, and b* = 10.80) even though muscle pH was not different between steer and heifer carcasses. Dairy-type carcasses (pH = 5.59, L* = 37.56, a* = 23.40, and b* = 9.68) had higher muscle pH values and lower colorimeter readings than either native-type (pH = 5.50, L* = 39.55, a* = 25.13, and b* = 11.00) or Brahman-type (pH = 5.46, L* = 39.75, a* = 25.17, and b* = 11.05) carcasses (P < 0.05).

An experiment was conducted to investigate pig performance, carcass quality, and palatability of pork from pigs fed distillers dried grains with solubles (DDGS), high-protein distillers dried grains (HPDDG), and corn germ. Eighty-four pigs (initial BW, 22 +/- 1.7 kg) were allotted to 7 dietary treatments with 6 replicates per treatment and 2 pigs per pen. Diets were fed for 114 d in a 3-phase program. The control treatment was based on corn and soybean meal. Two treatments were formulated using 10 or 20% DDGS in each phase. Two additional treatments contained HP-DDG in amounts sufficient to substitute for either 50 or 100% of the soybean meal used in the control treatment. An additional 2 treatments contained 5 or 10% corn germ, which was calculated to provide the same amount of fat as 10 or 20% DDGS. Results showed that for the entire experiment, pig performance was not affected by DDGS or HP-DDG, but final BW increased (linear, P < 0.05) as corn germ was included in the diets. Carcass composition and muscle quality were not affected by DDGS, but LM area and LM depth decreased (linear, P < 0.05) as HP-DDG was added to the diets. Lean meat percentage increased and drip loss decreased as corn germ was included in the diets (quadratic, P < 0.05). There was no effect of DDGS on fat quality except that belly firmness decreased (linear, P < 0.05) as dietary DDGS concentration increased. Including HP-DDG or corn germ in the diets did not affect fat quality, except that the iodine value increased (linear, P < 0.05) in pigs fed HP-DDG diets and decreased (linear, P < 0.05) in pigs fed corn germ diets. Cooking loss, shear force, and bacon distortion score were not affected by the inclusion of DDGS, HP-DDG, or corn germ in the diets, and the overall palatability of the bacon and pork chops was not affected by dietary treatment. In conclusion, feeding 20% DDGS or high levels of HP-DDG to growing-finishing pigs did not negatively affect overall pig performance, carcass composition, muscle quality, or palatability but may decrease fat quality. Feeding up to 10% corn germ did not negatively affect pig performance, carcass composition, carcass quality, or pork palatability but increased final BW of the pigs and reduced the iodine value of belly fat.

Bos indicus composite and Bos taurus cattle, originating from diverse production environments, were used to quantify genetic variation in marbling, 24-h calpastatin activity, and beef tenderness and to identify strategies for prevention of beef tenderness problems in Bos indicus composite cattle. Comparisons among 3/8 Bos indicus breeds (Braford, Red Brangus, Simbrah) revealed significant differences in marbling and 24-h calpastatin activity, but not in tenderness. Compared with Bos taurus cattle, 3/ 8 Bos indicus cattle had similar marbling scores but higher 24-h calpastatin activities. Also, beef from 3/8 Bos indicus composites aged more slowly from 1 to 7 d and was less tender at 4, 7, 14, 21, and 35 d postmortem than beef from Bos taurus cattle. However, beef from 3/8 Bos indicus cattle was relatively tender if it was aged for a sufficient period of time (21 d). The delayed response to aging and greater toughness of beef from 3/8 Bos indicus cattle was associated with Brahman breed effects and was not related to the Bos taurus germplasm source. Marbling was moderately heritable (.52 +/- .21) but exhibited positive genetic correlations with shear force at d 1 through 14 of aging, suggesting that, in these cattle, selection for increased marbling would have an unfavorable effect on beef tenderness. A low heritability estimate for 24-h calpastatin activity (.15 +/- .15), coupled with low genetic correlations between calpastatin activity and shear force at 7, 14, and 35 d, suggested that selection for low calpastatin activity would have little effect on aged beef tenderness. Panel tenderness and shear force at 7, 14, and 21 d were moderately heritable (.27 to .47), indicating that aged beef tenderness could be improved by direct selection (via progeny testing). Comparisons among Simbrah, Senegus x Simbrah, and Red Angus x Simmental steers showed that inclusion of a tropically adapted Bos taurus breed (Senepol) could be an effective strategy for preventing beef tenderness problems in heat-tolerant cattle.

One hundred beef carcasses were selected at three packing plants and were used to determine the relationship between glycolytic potential (GP) and dark, firm, and dry (DFD) beef and to determine the effects of DFD status and GP on cooked beef palatability. Eight individual muscles were excised from one hindquarter of each carcass at d 7 postmortem: longissimus lumborum, psoas major, gluteus medius, tensor fasciae latae, rectus femoris, semimembranosus, biceps femoris, and semitendinosus. Ultimate pH, colorimeter readings, and Warner-Bratzler shear force were determined for all eight muscles at d 7 postmortem. A nine-member trained sensory panel evaluated cooked longissimus lumborum, gluteus medius, and semimembranosus steaks. Traits determined solely for the longissimus lumborum were GP (2 x [glycogen + glucose + glucose-6-phosphate] + lactate) and ether-extractable fat. A curvilinear relationship existed between GP and ultimate pH within the longissimus muscle. There appeared to be a GP threshold at approximately 100 micromol/g, below which lower GP was associated with higher ultimate pH and above which GP had no effect on ultimate pH. The greatest pH and muscle color differences between normal and DFD carcasses were observed in the longissimus lumborum, gluteus medius, semimembranosus, and semitendinosus muscles. Cooked longissimus from DFD carcasses had higher shear force values (46% greater) and more shear force variation (2.3 times greater variation) than those from normal carcasses. Dark cutting carcasses also had higher shear force values for gluteus medius (33% greater) and semimembranosus (36% greater) than normal carcasses. Sensory panel tenderness of longissimus, gluteus medius, and semimembranosus was lower for DFD carcasses than for normal carcasses. Longissimus and gluteus medius flavor desirability scores were lower for DFD than for normal carcasses. Steaks from DFD carcasses had more off-flavor comments than steaks from normal carcasses, specifically more "peanutty," "sour," and "bitter" flavors. The DFD effect of higher shear force values was approximately five times greater (+3.11 kg vs +0.63 kg) for carcasses with "slight" marbling scores than for carcasses with "small" marbling scores. In general, higher GP was associated with increased tenderness, even among normal carcasses. In conclusion, low GP was associated with DFD beef and resulted in substantially less-palatable cooked steaks.