The effects of fat level and low fat formulation on survival of Escherichiu coli 0157:H7 isolate 204P heated in ground beef [7%, 10% and 20% fat], pork sausage [7%, lo%, and 30% fat], chicken (3% and 11% fat), and turkey (3% and 11% fat) were determined by D-and z-values. D-values for E. coli 0157:H7 in lowest fat products were lower than in traditional beef and pork products (P < 0.05). Overall, higher fat levels in all products resulted in higher D-values. D,, values (min) ranged from 0.4550.47 in beef, 0.37-0.55 in pork sausage, 0.38-0.55 in chicken and 0.5550.58 in turkey. D,, and D,, values were respectively longer. Zvalues ranged from 4.44.8"C. Product composition affected lethality of heat to E. coli 0157:H7.

The effects of added antioxidants on restructured combination (5050) beef-pork steaks were studied. Steaks were formulated to contain 20% fat and 0.75% salt. Antioxidants used at a 0.02% level (based on fat content of meat) were butylated hydroxyanisole (BHA), tertiary butyl hydroquinone (TBHQ), and a combination of BHA and TBHQ. Cooked steaks were evaluated for sensory properties and overall acceptability, initially and after 4, 8, 12, 16, an 20 wk of freezer storage. Steaks were also evaluated after the various storage times for 2-thiobarbituric acid (TBA) values, subjective color by panel evaluation, objective color with the Hunter color difference meter, tensile strength, shear value and cooking loss. Flavor and overall acceptability were significantly better in treated samples as compared to control samples. BHA was more effective in protecting color and TBHQ was more effective in protecting flavor (P

Restructured pork chops containing approximately 15% fat were manufactured from fresh hams and boston butts taken from sows. The effects of salt level (OS, OS%, l.O%, and 1.5%) and freezer storage time (0 and 30 days) on quality attributes of restructured pork chops were studied with three replications. Triangle test differences were significant for all comparisons except 1.0% and 1.5% salt groups stored for 30 days. 2-Thiobarbituric acid (TBA) values increased linearly with increasing salt levels for both 0 and 30 days storage. Salt addition also linearly increased Instron slicing strength values, and improved flavor, juiciness, and textural properties. The addition of salt decreased raw color evaluations, Instron shearing values and cooking losses. Following 30 days freezer storage, treatments containing salt had higher TBA values and lower color scores than the control treatment containing 0% salt. Salt addition at levels between 0.5 and 1.0% is recommended for restructured pork chops.

This study investigated the effect of mixing and grinding, tempering, addition of sodium chloride and sodium tripolyphosphate and processing under a nitrogen atmosphere on the color of restructured beef steaks initially and at I-month intervals for 3 months of frozen storage. Mixing and grinding and manufacture under a nitrogen atmosphere had the greatest detrimental effect on the extent of discoloration initially; this was probably due to low oxygen concentration. Tempering and the addition of sodium chloride without sodium tripolyphosphate produced the most rapid increase in rate of discoloration during frozen storage. Tripolyphosphate partially counteracted the detrimental effect of sodium chloride, however, this effect did not appear to be due to the higher pH produced by the phosphate or the chelating ability of the phosphate. Surface discoloration and overall color were highly correlated with surface metmyoglobin (r= -0.87) and overall metmyoglobin (r= -0.94).

Ten muscles and muscle groups were excised from each of eight typical (average yield grade 2.99) and eight lean (average yield grade 1.73) steer carcasses and analyzed to determine differences between carcass types. Lean carcasses (raw basis) were higher (PcO.05) in moisture and protein and lower (PcO.05) in fat, cholesterol and calories in comparison to typical carcasses. Typical carcasses (cooked basis) were higher (PcO.05) in fat and caloric content than lean carcasses. No differences (P>O.O5) were found between carcass types (cooked basis) for moisture, protein, cholesterol, dry matter cholesterol, cooking loss or shear force value. Semitendinosus muscles from typical carcasses were rated higher (PcO.05) for juiciness and tenderness than from lean carcasses. Differences (PcO.05) were found among muscles for all traits measured.