The paper outlines the technique and shows the findings of a multifactorial study. It is connected with the working process of a vibrating unit designed for the non-destructive removal of organic components, mainly beebread, from honeycombs. The honeycombs should be cleaned from the beebread prior to their reheating (in case of their rejection), or for reuse as nest-based honeycomb frames. The aim of the experiment described in the paper is to establish the influence of the main operating parameters of vibration cleaning of honeycombs such as the frequency and amplitude of vibration on the productivity of the workflow. The study was performed on a specially manufactured laboratory unit consisting of a shaking table, controls, measuring devices and sensors. The specific feature of the conducted study is the uneven intensity of beebread extraction from honeycomb cells during the working cycle, which should be considered during the experiment.
В данной статье представлены результаты исследования оптических характеристик перговых сотов с применением ИКспектроскопии. Данные исследования необходимо учитывать при использовании инфракрасной сушки, отличительной особенностью которой является то, что интенсивность нагрева зависит только от оптических характеристик продукта. В статье рассмотрена конструкция и принцип работы ИКФурье спектрометра, основной частью которого является интерферометр Майкельсона. Исследование оптических характеристик перговых сотов во всех диапазонах инфракрасного излучения производили в ИКФурье спектрометре PerkinElmer Frontier. Для проведения исследования из заранее осушенных от меда сотов формировали по два образца размером 5050 м, заполненных пергой, после чего один из образцов подвергали конвективной сушке на протяжении 50 часов. Методика проведения исследования и общий вид установки во время проведения исследования оптических характеристик перговых сотов описаны в статье. По результатам исследования были построены спектральные характеристики перговых сотов. Полученные результаты эксперимента показывают, что перговые соты являются хорошим поглотителем ИК энергии. Из полученных данных видно, что с увеличением длин волн значение коэффициента отражения увеличивается. Степень черноты перговых сотов практически не зависит от влажности и происхождения, а ее среднее значение составляет 0,8850,886. В свою очередь, значение нормального коэффициента отражения незначительно уменьшается с 0,0581 до 0,0575. Анализ спектральных характеристик перговых сотов показывается явно выраженные минимумы отражения ИКизлучения, которые могут быть использованы для выбора оптимальной температуры нагревателей в процессе сушки.This article presents the results of the study of the optical characteristics of honeycombs using infrared spectroscopy. These researches should be considered when using infrared drying, a distinctive feature of which is that the heating intensity depends only on the optical characteristics of the product. The article describes the design and principle of operation of the FTIR spectrometer. The research of the optical characteristics of honeycombs in all ranges of infrared radiation was carried out in a PerkinElmer Frontier FTIR spectrometer, the main part of which is the Michelson interferometer.. For the research, combs of 50 50 mm size filled with bee bread were formed from honeycombs that had been drained from honey beforehand, after which one of the samples was subjected to convective drying for 50 hours. The technique of the research and the general view of the installation during the research of the optical characteristics of the honeycombs are described in the article. According to the results of the study, spectral characteristics of honeycombs were constructed. The results of the research show that the honeycombs are a good absorber of IR energy. From the data obtained it can be seen that with increasing wavelengths the value of the reflection coefficient increases. Emissivity of honeycombs is almost independent of humidity and origin, and its average value is 0.8850.886. In turn, the value of the normal reflection coefficient decreases slightly from 0.0581 to 0.0575. The analysis of the spectral characteristics of the honeycombs shows pronounced minima of the reflection of infrared radiation, which can be used to select the optimum temperature of the heaters during the drying process.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.