Bioreactor heterogeneity has been studied in a multiconfigurable pilot-scale airlift reactor (0.25 m 3 ) which created different degrees of heterogeneity. The impact of the two sparger configurations, i.e. in the draft tube or the annulus, in conjunction with a marine propeller fitted at the base of the downcomer, on the physiology of Saccharopolyspora erythraea was studied. Cellular growth, morphology, and productivity were compared between airlift and stirred tank reactors. Dissolved oxygen tension heterogeneity caused by differences in dissolved oxygen tension around the vessel did not affect growth, but the reduction of heterogeneity improved the specific erythromycin production rate and final specific production. Erythromycin production was shown to be proportional to the energy dissipation rate. The enhancement of bubble coalescence with increasing apparent viscosity led to the reduction of the sectional gas holdups and the improvement of liquid mixing. The extent of the changes with increasing apparent viscosity was dependent on the broth morphology, reactor configurations, and operating conditions.
Hydrodynamic and oxygen transfer comparisons were made between two ring sparger locations, draft tube and annulus, in a concentric pilot scale airlift reactor with a baker's yeast suspension. Sectional hydrodynamic measurements were made and a mobile DOT probe was used to characterise the oxygen transfer performance through the individual sections of the reactor.The hydrodynamic performance of the reactor was improved by using a draft tube ring sparger rather than the annulus ring sparger. This was due to the influence of the ratio of the cross sectional area of the downcomer and riser (A D /A R ) in conjunction with the effect of liquid velocity and a parameter, C 0 , describing the distribution of the liquid velocity and gas holdup across the riser on the bubble coalescence rates.The mixing performance of the reactor was dominated by the frequency of the passage of the broth through the end sections of the reactor. An optimum liquid height above the draft tube for liquid mixing was demonstrated, above which no further improvement in mixing occurred. The liquid velocity and degree of gas entrainment showed little dependency on top section size for both sparger configurations.Extreme dissolved oxygen heterogeneity was demonstrated around the vessel with both sparger configurations and was shown to be detrimental to the oxygen uptake rate of the baker's yeast. Dissolved oxygen tensions below 1% air saturation occurred along the length of the riser and then rose in the downcomer. The greater oxygen transfer rate in the downcomer than in the riser was caused by the combined effects of a larger slip velocity in the downcomer which enhanced k L a and gas residence time, high downcomer gas holdup, and the change in bubble size distribution between the
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
customersupport@researchsolutions.com
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.