An experiment was conducted to evaluate the influence of a novel microbial phytase on performance, tibia ash, and the content of phytate, phytate esters, and inositol in the gizzard of young broilers. Male Cobb 500 broilers (n = 1,680) were fed 1 of 7 experimental diets: positive control (PC) formulated to meet or exceed nutrient recommendations; PC plus dicalcium phosphate (PC+DCP) formulated to provide Ca and P at 0.10% above the PC; PC plus 500 U/kg of microbial phytase (PC+500); negative control (NC) with Ca and P reduced from the PC by 0.16% and 0.15%, respectively; and the NC plus phytase at 500 (NC+500), 1,000 (NC+1,000), or 1,500 (NC+1,500) U/kg. Diets were fed in crumbled form to 20 birds/pen and 12 replicate pens/diet from d 0 to 21. On d 21, 4 birds/pen were euthanized for collection of right tibias and gizzard digesta for determination of tibia ash and gizzard phytate. In general, broilers fed the NC diet had reduced (P ≤ 0.05) feed intake and BW gain compared with broilers fed diets supplemented with phytase, but not different than the PC or PC+DCP. Phytase supplementation in the NC diet improved (P ≤ 0.05) BW gain comparable with or above that of the PC. Feed conversion ratio was improved in broilers fed the NC+1,000 or NC+1,500 compared with broilers fed all other diets. Tibia ash was reduced (P ≤ 0.05) in broilers fed the NC compared with broilers fed all other diets, and phytase supplementation improved tibia ash comparable with the PC. Phytase supplementation reduced (P ≤ 0.05) phytate (inositol hexa-phosphate) concentration in the gizzard. Inositol concentration in the gizzard was higher (P ≤ 0.05) in birds fed NC+1,000 or NC+1,500 compared with all other diets and this was correlated with growth performance (P ≤ 0.05) rather than tibia ash (P > 0.05). Improvements in feed conversion ratio associated with superdoses of phytase may be attributed to phytate destruction and the provision of inositol.

The incidence of woody breast (WB) is increasing on a global scale representing a significant welfare problem and economic burden to the poultry industry and for which there is no effective treatment due to its unknown etiology. In this study, using diffuse reflectance spectroscopy (DRS) coupled with iSTAT portable clinical analyzer, we provide evidence that the circulatory- and breast muscle-oxygen homeostasis is dysregulated [low oxygen and hemoglobin (HB) levels] in chickens with WB myopathy compared to healthy counterparts. Molecular analysis showed that blood HB subunit Mu (HBM), Zeta (HBZ), and hephaestin (HEPH) expression were significantly down regulated; however, the expression of the subunit rho of HB beta (HBBR) was upregulated in chicken with WB compared to healthy counterparts. The breast muscle HBBR, HBE, HBZ, and hypoxia-inducible factor prolyl hydroxylase 2 (PHD2) mRNA abundances were significantly down regulated in WB-affected compared to normal birds. The expression of HIF-1α at mRNA and protein levels was significantly induced in breasts of WB-affected compared to unaffected birds confirming a local hypoxic status. The phosphorylated levels of the upstream mediators AKT at Ser473 site, mTOR at Ser2481 site, and PI3K P85 at Tyr458 site, as well as their mRNA levels were significantly increased in breasts of WB-affected birds. In attempt to identify a nutritional strategy to reduce WB incidence, male broiler chicks (Cobb 500, n = 576) were randomly distributed into 48 floor pens and subjected to six treatments (12 birds/pen; 8 pens/treatment): a nutrient adequate control group (PC), the PC supplemented with 0.3% myo-inositol (PC + MI), a negative control (NC) deficient in available P and Ca by 0.15 and 0.16%, respectively, the NC fed with quantum blue (QB) at 500 (NC + 500 FTU), 1,000 (NC + 1,000 FTU), or 2,000 FTU/kg of feed (NC + 2,000 FTU). Although QB-enriched diets did not affect growth performances (FCR and FE), it did reduce the severity of WB by 5% compared to the PC diet. This effect is mediated by reversing the expression profile of oxygen homeostasis-related genes; i.e., significant down regulation of HBBR and upregulation of HBM, HBZ, and HEPH in blood, as well as a significant upregulation of HBA1, HBBR, HBE, HBZ, and PHD2 in breast muscle compared to the positive control.

An experiment was conducted to test the hypothesis that values for apparent total tract digestibility (ATTD) of Ca in pigs are influenced by endogenous Ca lost from the gastrointestinal tract. The objective was to determine the endogenous loss of Ca, the ATTD of Ca, and the true total tract digestibility (TTTD) of Ca in canola meal without and with microbial phytase. The second objective was to determine the balance of Ca in pigs fed diets based on canola meal without or with microbial phytase. Forty-eight growing barrows (initial BW: 16.72 ± 2.52 kg) were allotted to 8 dietary treatments in a randomized complete block design with 6 pigs per treatment. Diets were based on sucrose, cornstarch, potato protein isolate, corn gluten meal, and canola meal. Diets were formulated to contain 0.08, 0.16, 0.24, or 0.32% Ca from canola meal. All diets were formulated with 0 or 1,500 units/kg of microbial phytase and contained 0.32% digestible P. Feces and urine samples were collected from d 6 to 11. Total endogenous losses of Ca were determined using the regression procedure. Results indicated that ATTD of Ca and Ca retention increased (P < 0.05) if dietary Ca increased and also increased (P < 0.01) when phytase was added to the diets. The estimated total endogenous loss of Ca was 0.160 and 0.189 g/kg DMI for canola meal without and with microbial phytase, respectively, and these values were not different. The TTTD of Ca increased (P < 0.01) if phytase was used but was not affected by the level of dietary Ca. As dietary Ca increased, the amount of Ca absorbed and retained increased (P < 0.01) to a greater extent if phytase was used than when no phytase was included in the diet (interaction, P < 0.05). Fecal P excretion increased (P < 0.01) as dietary Ca increased but was reduced (P < 0.01) by the use of phytase. The ATTD of P decreased (P < 0.01) with increasing dietary Ca to a lesser extent if phytase was used than when no phytase was used (interaction, P < 0.01). In conclusion, endogenous Ca is lost from the gastrointestinal tract of growing pigs, and values for TTTD of Ca are, therefore, different from values for ATTD of Ca. Values for ATTD of Ca are influenced by level of dietary Ca, but that is not the case for values for TTTD of Ca. The ATTD of P decreases as dietary Ca increases, but microbial phytase increases Ca and P digestibility and Ca retention in pigs fed diets based on canola meal whereas it does not influence endogenous losses of Ca.

An experiment was conducted to test the hypothesis that differences in the apparent total tract digestibility (ATTD) and standardized total tract digestibility (STTD) of Ca exist among Ca supplements and that inclusion of microbial phytase increases the ATTD and STTD of Ca. One hundred and four growing barrows (average initial BW of 17.73 ± 2.53 kg) were allotted to a randomized complete block design with 13 dietary treatments and 8 pigs per treatment. A basal diet containing corn, cornstarch, potato protein isolate, soybean oil, calcium carbonate, monosodium phosphate, vitamins, and minerals was formulated. Five additional diets were formulated by adding monocalcium phosphate (MCP), dicalcium phosphate (DCP), calcium carbonate, Lithothamnium calcareum Ca, or a high-Ca sugar beet co-product to the basal diet at the expense of cornstarch. Six additional diets that were similar to the previous 6 diets with the exception that they also contained 500 units per kilogram of microbial phytase were also formulated. A Ca-free diet was used to determine basal endogenous losses of Ca. Feces were collected using the marker-to-marker approach. Results indicated that regardless of inclusion of microbial phytase, MCP had the greatest (P < 0.05) ATTD and STTD of Ca. The ATTD and STTD of Ca in DCP were greater (P < 0.05) than in calcium carbonate, L. calcareumC a, or in the sugar beet co-product, but no differences were observed among the ATTD and STTD of Ca in calcium carbonate, L. calcareum Ca, or sugar beet co-product. Inclusion of microbial phytase increased (P < 0.05) the ATTD and STTD of Ca in the diets, but this was not the case in the Ca supplements. Regardless of inclusion of microbial phytase, the ATTD of P was greater ( P< 0.05) in pigs fed basal, MCP, or DCP diets than in pigs fed calcium carbonate, L. calcareum Ca, or the sugar beet co-product, but pigs fed calcium carbonate diets had greater ( P< 0.05) ATTD of P than pigs fed L. calcareumCa or the sugar beet co-product. Regardless of Ca source, inclusion of microbial phytase increased (P < 0.001) the ATTD of P. In conclusion, MCP has the greatest ATTD and STTD of Ca among the calcium supplements used in this experiment, followed by DCP. Basal, MCP, and DCP diets had greater ATTD of P than the other diets, and inclusion of microbial phytase increased the ATTD and STTD of Ca and the ATTD of P in the diets.

An experiment was conducted to determine the influence of 2 levels of dietary Ca from limestone and 3 levels of phytase on broiler performance, bone ash, gastrointestinal pH, and apparent ileal digestibility (AID) of Ca, P, and amino acids. Cobb 500 broilers (n = 576) were allowed access to one of 6 corn-soy diets from 0 to 16 d. Experimental diets contained 1.03% or 0.64% Ca from limestone and 0.61% total P. Each diet was supplemented with 0, 500, or 5,000 FTU/kg of phytase to create a 2 × 3 factorial experiment. Broiler feed intake (FI) and BW gain were not affected by dietary Ca or phytase. Feed conversion ratio was improved (P < 0.05) as dietary phytase increased (1.36, 1.34, and 1.31, respectively). Tibia ash percent was reduced (P < 0.05) from 41.4 to 40.0% as dietary Ca decreased but increased with phytase addition (P < 0.05). Gizzard and ileal pH were reduced (P < 0.05) in broilers fed 0.64% Ca compared with broilers fed 1.03% Ca. Phytase at 5,000 FTU/kg increased (P < 0.05) pH in the gizzard, duodenum, jejunum, and ileum. Apparent ileal P digestibility was increased (P < 0.05) in broilers fed 0.64% Ca compared with broilers fed 1.03% Ca (0.68 vs. 0.73, respectively). Apparent ileal Ca digestibility was increased (P < 0.05) in broilers fed 1.03% Ca compared with broilers fed 0.64% Ca (0.67 vs. 0.53, respectively). Phytase improved AID of CP in broilers fed 1.0% Ca but did not have an effect on AID of CP in broilers fed 0.64% Ca, which resulted in a Ca × phytase interaction (P < 0.05). In conclusion, high dietary Ca increased pH in gizzard and ileum and interfered with the AID of P and CP. The interactions between Ca and phytase in the gastrointestinal tract are complex, and feeding phytase at doses above industry recommendations may allow for reduced-Ca diets while maintaining broiler performance, bone ash, and improving amino acid digestibility.