The purpose of the present study was characterization of microparticles obtained by adsorption of poorly water soluble drug, meloxicam, on a porous silicate carrier Florite RE (FLR) and development of a tablet formulation using these microparticles, with improved drug dissolution properties. The study also reveals the use of FLR as a pharmaceutical excipient. Meloxicam was adsorbed on the FLR in 2 proportions (1:1 and 1:3), by fast evaporation of solvent from drug solution containing dispersed FLR. Drug adsorbed FLR microparticles were evaluated for surface topography, thermal analysis, X-ray diffraction properties, infrared spectrum, residual solvent, micromeritic properties, drug content, solubility, and dissolution studies. Microparticles showed bulk density in the range of 0.10 to 0.12 g/cm(3). Dissolution of drug from microparticles containing 1:3, drug:FLR ratio was faster than microparticles containing 1:1, drug:FLR ratio. These microparticles were used for formulating directly compressible tablets. Prepared tablets were compared with a commercial tablet. All the prepared tablets showed acceptable mechanical properties. Disintegration time of prepared tablets was in the range of 18 to 38 seconds, and drug dissolution was much faster in both acidic and basic medium from prepared tablets as compared with commercial tablet. The results suggest that FLR provides a large surface area for drug adsorption and also that a reduction in crystallinity of drug occurs. Increase in surface area and reduction in drug crystallinity result in improved drug dissolution from microparticles.
Abstract. The purpose of the present work was the development and evaluation of stomach-specific controlled release mucoadhesive drug delivery system prepared by ionotropic gelation of gellan beads, containing acid-soluble drug amoxicillin trihydrate, using 3 2 factorial design with concentration of gellan gum and quantity of drug as variables. The study showed that beads prepared in alkaline cross-linking medium have higher entrapment efficiency than the acidic cross-linking medium. The entrapment efficiency was in the range of 32% to 46% w/w in acidic medium, which increased up to 60% to 90% w/w in alkaline medium. Batches with lowest, medium, and highest drug entrapment were subjected to chitosan coating to form a polyelectrolyte complex film. As polymer concentration increases, entrapment efficiency and particle size increases. Scanning electron microscopy revealed spherical but rough surface due to leaching of drug in acidic cross-linking solution, dense spherical structure in alkaline cross-linking solution, and rough surface of chitosan-coated beads with minor wrinkles. The in vitro drug release up to 7 h in a controlled manner following the Peppas model (r=0.9998). In vitro and in vivo mucoadhesivity study showed that beads have good mucoadhesivity and more than 85% beads remained adhered to stomach mucosa of albino rat even after 7 h. In vitro growth inhibition study showed complete eradication of Helicobacter pylori. These results indicate that stomach-specific controlled release mucoadhesive system of amoxicillin gellan beads may be useful in H. pylori treatment.
Celecoxib exhibits poor flow properties and compressibility. Spherical crystallization of celecoxib was carried out using the solvent change method. An acetone:dichloromethane (DCM):water system was used where DCM acted as a bridging liquid and acetone and water as good and bad solvent, respectively. Hydroxypropylmethylcellulose (HPMC) was used to impart strength and sphericity to the agglomerates. The effect of amount of bridging liquid and speed of agitation was studied using 3(2) factorial design. Primary properties of the agglomerates were evaluated by infrared spectroscopy, powder X-ray diffraction, and differential scanning calorimetry. The effect of variables on micromeritic, mechanical, compressional, and dissolution behavior was evaluated by response surface methodology. Particle size, bulk density, mean yield pressure (MYP), and drug release were found to be significantly affected by either of the two variables. Interaction of variables significantly affected the MYP.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.