Fed-batch production of recombinant beta-galactosidase in E. coli was studied with respect to the specific growth rate at induction. The cultivations were designed to induce protein production by IPTG at a glucose feed rate corresponding to high mu = 0.5 h(-1)) or low (mu = 0.1 h(-1)) specific growth rate. Protein production rate was approximately 100% higher at the higher specific growth rate, resulting in the accumulation of beta-galactosidase up to 30% of the total cell protein. Transcription analysis showed that beta-galactosidase-specific messenger RNA was immediately formed after induction (<5 min), but the amount was the same in both cases and was thus not the initial limiting factor. The content of ribosomes, as represented by rRNA, rapidly decreased with specific growth rate from a relative level of 100%, at the high specific growth rate, to 20% at the low specific growth rate. At high specific growth rate, ribosomes were additionally degraded upon induction due to the high production level. Translation therefore seemed to be the initial limiting factor of the protein synthesis capacity. The alarmone guanosine tetraphosphate increased at both high and low feed level inductions, indicating an induction-forced starvation of charged tRNA and/or glucose. The altered physiological status was also detected by the formation of acetic acid. However, the higher production rate resulted in high-level accumulation of acetic acid, which was absent at low feed rate production. Acetic acid production is thus coupled to the high product formation rate and is proposed to be due either to a precursor drain of Krebs cycle intermediates and a time lag before induction of the glyoxalate shunt, or to single amino acid overflow, since the model product is relatively poor in glycin and alanin. In conclusion, it is proposed that production at high specific growth rate becomes precursor-limited, while production at low specific growth rate is carbon- and/or energy-limited.

The use of the uspA and uspB promoters (universal stress promoters) for heterologous protein production in Escherichia coli is described. Best results were obtained with a moderate copy number vector (15-60 copies) bearing the uspA promoter, reaching 4.6 mg/g dry cell weight (DCW) of ZZ-proinsulin secreted to the periplasm and 1.9 mg/g DCW secreted to the culture medium. These values are about 1.7-fold higher than those previously reported with the same ZZ fusion tag and the SpA leader peptide showing that these stress promoters are potentially valuable for recombinant protein secretion in E. coli. It is further demonstrated that the use of M9 minimal medium is advantageous for protein secretion as compared to LB rich medium.

From the hypothesis that the rate of expression of a nascent polypeptide controls the accumulation of soluble full-length protein, accumulation of the model fusion proteins Zb-MalE and Zb-MalE31, were studied. MalE and MalE31 are two isoforms of the maltose binding protein, differing only in two consecutive amino acids. Parameters controlling the expression rate were the transcription rate, which was controlled by IPTG induction of the lacUV5 promoter and the substrate addition levels during fed-batch cultivation. Results show that the two product proteins appear in both soluble and insoluble fractions during cultivation and are both subjected to proteolysis. However, the accumulation of the soluble form of Zb-MalE31 protein is radically lower, at all conditions, due to the small difference in primary structure. It was shown that both proteolysis and inclusion body formation could be influenced by the selected parameters although a change in feed rate had a considerably higher effect. A high concentration of inducer and a "high" feed rate result in a low accumulation of soluble product, due to a high proteolysis. The concentration of inducer leading to different levels of transcription is, however, an efficient tool to influence inclusion body formation. At low IPTG concentrations (< or = 5 microM), this formation is almost abolished while at a comparatively high concentration (> or = 300 microM) 50% of the total product accumulated was in the form of inclusion bodies.

The effect of changes in substrate feed rate during fedbatch cultivation was investigated with respect to soluble protein formation and transport of product to the periplasm in Escherichia coli. Production was transcribed from the P(malK) promoter; and the cytoplasmic part of the production was compared with production from the P(lacUV5) promoter. The fusion protein product, Zb-MalE, was at all times accumulated in the soluble protein fraction except during high-feed-rate production in the cytoplasm. This was due to a substantial degree of proteolysis in all production systems, as shown by the degradation pattern of the product. The product was also further subjected to inclusion body formation. Production in the periplasm resulted in accumulation of the full-length protein; and this production system led to a cellular physiology where the stringent response could be avoided. Furthermore, the secretion could be used to abort the diauxic growth phase resulting from use of the P(malK) promoter. At high feed rate, the accumulation of acetic acid, due to overflow metabolism, could furthermore be completely avoided.