BackgroundMicrobial cell population heterogeneity is now recognized as a major source of issues in the development and optimization of bioprocesses. Even if single cell technologies are available for the study of microbial population heterogeneity, only a few of these methods are available in order to study the dynamics of segregation directly in bioreactors. In this context, specific interfaces have been developed in order to connect a flow cytometer directly to a bioreactor for automated analyses. In this work, we propose a simplified version of such an interface and demonstrate its usefulness for multiplexed experiments.ResultsA low-cost automated flow cytometer has been used in order to monitor the synthesis of a destabilized Green Fluorescent Protein (GFP) under the regulation of the fis promoter and propidium iodide (PI) uptake. The results obtained showed that the dynamics of GFP synthesis are complex and can be attributed to a complex set of biological parameters, i.e. on the one hand the release of protein into the extracellular medium and its uptake modifying the activity of the fis promoter, and on the other hand the stability of the GFP molecule itself, which can be attributed to the protease content and energy status of the cells. In this respect, multiplexed experiments have shown a correlation between heat shock and ATP content and the stability of the reporter molecule.ConclusionThis work demonstrates that a simplified version of on-line FC can be used at the process level or in a multiplexed version to investigate the dynamics of complex physiological mechanisms. In this respect, the determination of new on-line parameters derived from automated FC is of primary importance in order to fully integrate the power of FC in dedicated feedback control loops.

In this work, we present the design and characterization of Green Fluorescent Protein (GFP)-based reporter systems designed to describe cellular activity in "complex," heterogeneous bioreactors. The reporter systems consist of Escherichia coli strains carrying growth dependent promoters fused to genes expressing stable and unstable variants of GFP, respectively. The response of Escherichia coli cells to transient exposure to glucose was studied in a two-compartment scale down bioreactor (SDR) consisting of a well-stirred tank reactor (STR) connected to a plug-flow reactor (PFR). Such a SDR system is employed to mimic the situation of high glucose concentration and oxygen limitation that often encountered in large-scale, fed-batch bioreactors and the response of E. coli was simulated by continuously pumping microbial cells from STR to the PFR. We found that repeated addition of concentrated glucose pulses with varied frequency at the entrance of the PFR had consequences on strain physiological behavior. The GFP expressions were significantly marked after 10 h of cultivation in STR (control reactor) and SDR, whereas, growth rates were rather similar. Additional experiments in chemostat with programmed glucose perturbation suggested that the activities of the promoters were linked with the substrate limitation signal. Taken together with immunoblot analysis, we suppose protein leakage is responsible for the overexpression of fis and the related promoters, such as rrnB in this case study, but additional works are required in order to confirm this relationship. This investigation is useful for a better understanding of the fast dynamic phenomena occurring in heterogeneous large-scale bioreactors.

Noise in gene and protein expression is a major cause for bioprocess deviation. However, this phenomenon has been only scarcely considered in real bioprocessing conditions. In this work, a scaling-law derived from genome-scale studies based on GFP reporter systems has been calibrated to an on-line flow cytometry device, allowing thus to get an insight at the level of promoter activity and associated noise during a whole microbial culture carried out in bioreactor. We show that most of the GFP reporter systems investigated and thus corresponding genes could be included inside the area covered by the scaling-law. The experimental results suggest that this scaling-law could be used to predict the dynamics of promoter activity, as well as the associated noise, in bioprocessing conditions. The knowledge acquired throughout this work could be used for the design of more robust expression systems.

Phosphate minerals have long been used for the production of phosphorus-based chemicals used in many economic sectors. However, these resources are not renewable and the natural phosphate stocks are decreasing. In this context, the research of new phosphate sources has become necessary. Many types of wastes contain non-negligible phosphate concentrations, such as wastewater. In wastewater treatment plants, phosphorus is eliminated by physicochemical and/or biological techniques. In this latter case, a specific microbiota, phosphate accumulating organisms (PAOs), accumulates phosphate as polyphosphate. This molecule can be considered as an alternative phosphate source, and is directly extracted from wastewater generated by human activities. This review focuses on the techniques which can be applied to enrich and try to isolate these PAOs, and to detect the presence of polyphosphate in microbial cells.

No abstract

Protein leakage is induced in well-mixed fed-batch bioreactor by comparison with cultures carried out in scale-down conditions. This effect is attributed to a progressive increase of cell membrane permeability and the synthesis of several outer-membrane components allowing to cope with substrate limitation commonly found in high cell density culture. A comparative analysis of protein leakage has thus been performed in well-mixed bioreactors and in scale-down devices. The extracellular proteome of E.coli has been investigated by 2D-gel electrophoresis and identified by subsequent MALDI-TOF analysis. On 110 picked spots, 67 proteins have been identified and the sub-localisation and the molecular function of these proteins have been determined. A majority of the extracellular proteome was composed of outer-membrane and periplasmic proteins (64 %) confirming the fact that leakage is involved in high cell density cultures. About 50 % of this extracellular proteome was composed of transport and binding proteins. Furthermore, the more abundant spots on the gel corresponded to porin proteins and periplasmic transporters. In particular, the OmpC porin was found to be very abundant. Moreover, the scale-down effect on this extracellular proteome has been investigated by two-dimensional differential in-gel electrophoresis analysis (2D-DIGE), and significant differences have been observed by comparison with culture carried out in well-mixed systems. Indeed, since substrate limitation signal is alleviated in this kind of apparatus, cell permeability was lowered as shown by flow cytometry. In scale-down conditions, protein leakage was thus less abundant.

Mixing deficiencies can be potentially detected by the use of a dedicated whole cell microbial biosensor. In this work, a csiE promoter induced under carbon-limited conditions was involved in the elaboration of such biosensor. The cisE biosensor exhibited interesting response after up and down-shift of the dilution rate in chemostat mode. Glucose limitation was accompanied by green fluorescent protein (GFP) leakage to the extracellular medium. In order to test the responsiveness of microbial biosensors to substrate fluctuations in large-scale, a scale-down reactor (SDR) experiment was performed. The glucose fluctuations were characterized at the single cell level and tend to decrease the induction of GFP. Simulations run on the basis of a stochastic hydrodynamic model have shown the variability and the frequencies at which biosensors are exposed to glucose gradient in the SDR. GFP leakage was observed to a great extent in the case of a culture operated in well-mixed fed-batch mode, by comparison with those operated in SDR. GFP leakage seems to be correlated to a higher membrane permeability, confirming previous studies highlighting a better cell viability in cultures operated in a fluctuating environment. Our results suggest that GFP leakage could be used in parallel to the normal GFP biosensor function in order to assess microbial viability in process conditions.

Substrate limitation responsive biosensors have been used for the development of a mini-bioreactor platform that can be used as a scale-down tool. Three green fluorescent protein (GFP) transcriptional reporters have been chosen in Escherichia coli, i.e., uspA::gfp, csiE::gfp, and yciG::gfp. Our previous studies have shown that these kinds of promoters are induced in response to substrate limitation and are significantly repressed when cultures are carried out in heterogeneous bioreactors. This sensitivity to substrate limitation has been confirmed in the case of the csiE and yciG biosensors. A mini-scale-down platform is proposed as a high throughput tool to rapidly investigate the usefulness of a given microbial biosensor. This platform is composed of shake flasks able to operate in fed-batch mode either using the slow release or the intermittent feeding principle. Local heterogeneities were reproduced at the level of these mini-bioreactors (operating under the intermittent feeding principle) and caused a decrease in GFP expression as in conventional scale-down reactors. The presence of GFP in supernatants was also noted and seems to be correlated with the substrate limitation signal for the three cultivation systems considered in this work (i.e., chemostat, conventional and mini-bioreactors) and with membrane permeability.