Studying a Multi-Stage Flash Brine Recirculation (MSF-BR) System Based on Energy, Exergy and Exergoeconomic Analysis

Abstract

Due to the lack of natural water resources and high consumption of water in industries, desalination systems are good options to supply water demands, especially in regions with a water crisis. If these wastes are used in thermal desalination cycles, in addition to improving efficiency and reducing energy consumption, the production of environmental pollutants can also be reduced. In this paper, the multi-stage flash brine recirculation (MSF-BR) system of the Abadan refinery is investigated from energy-exergy-exergoeconomic viewpoints. In addition, the effects of top brine temperature (TBT), number of stages and ambient temperature on the performance of the system are evaluated. The results at maximum brine temperature show that with increasing the TBT, the exergy efficiency, gained output ratio (GOR) and distillate water production increase by 34%, 47% and 47%, respectively. It is also found that if the number of stages in the heat rejection section increases to more than six stages, GOR will decrease. The exergoeconomic analysis results reveal that the relative cost difference increases by 94% with an increase in the number of stages. Finally, it is concluded that by using the waste heat of a refinery complex for heating steam to run the desalination system, there is a 9103 $/year cost savings due to energy consumption reduction and 193 × 104 $/year cost savings due to CO2 emission reduction.

A 3E analysis of a multi‐power generation system employing CO2, LNG, and Organic Rankine cycles

“…In this study, multi-objective optimization is conducted to increase the system exergy, decrease costs, and increase the net output work of the system by the following equations 57 : F I G U R E 7 Pareto solution curve for pinch point temperature of vapor generator and ORC turbine inlet pressure, and selected optimal point with TOPSIS method.…”

“…In this study, multi‐objective optimization is conducted to increase the system exergy, decrease costs, and increase the net output work of the system by the following equations 57 :…”

Experimental Investigation of the Innovative Small Hybrid Desalination Plant Powered by PVT Panel for Remote Regions

“…Desalination has shown a great role in affording freshwater from saline water. Many desalination methods were approached and tested for freshwater production like multi-stage flash desalination (MSF) [2][3][4][5][6], Electrodialysis (ED) [7,8], Reverse Osmosis (RO) [9,10], Solar stills [11][12][13] and other methods.…”

Thermodynamic feasibility and multiobjective optimization of a closed Brayton cycle-based clean cogeneration system

“…Today, the energy crisis, the increase in greenhouse gas emissions and global warming are critical challenges in the world, especially in developing countries, and the optimal and correct use of energy can be a suitable solution for these problems. For this reason, a lot of research has been done in this field, but more research is needed [45][46][47][48][49][50][51][52][53][54][55].…”