Formal recycling of e-waste leads to increased exposure to toxic metals: An occupational exposure study from Sweden

Abstract

Electrical and electronic waste (e-waste) contains multiple toxic metals. However, there is currently a lack of exposure data for metals on workers in formal recycling plants. The objective of this study was to evaluate workers' exposure to metals, using biomarkers of exposure in combination with monitoring of personal air exposure. We assessed exposure to 20 potentially toxic metals among 55 recycling workers and 10 office workers at three formal e-waste recycling plants in Sweden. Workers at two of the plants were followed-up after 6 months. We collected the inhalable fraction and OFC (37-mm) fraction of particles, using personal samplers, as well as spot samples of blood and urine. We measured metal concentrations in whole blood, plasma, urine, and air filters using inductively coupled plasma-mass spectrometry following acid digestion. The air sampling indicated greater airborne exposure, 10 to 30 times higher, to most metals among the recycling workers handling e-waste than among the office workers. The exposure biomarkers showed significantly higher concentrations of chromium, cobalt, indium, lead, and mercury in blood, urine, and/or plasma of the recycling workers, compared with the office workers. Concentrations of antimony, indium, lead, mercury, and vanadium showed close to linear associations between the inhalable particle fraction and blood, plasma, or urine. In conclusion, our study of formal e-waste recycling shows that workers performing recycling tasks are exposed to multiple toxic metals.

A Pilot Assessment of Occupational Health Hazards in the US Electronic Scrap Recycling Industry

“…Audiometry and blood lead level tests are good practices for an e-scrap recycling facility given that lead and noise are common hazards in this industry. (5,15,16) It was encouraging to see that all 22 facilities that reported blood lead monitoring had a pre-placement assessment of the employees. However, it is unclear why only five facilities followed their employees annually and four bi-annually.…”

“…(3) In 2011, more than 4.4 million tons of used and end-of-life electronic devices were recycled. (1) E-scrap contains more than 1000 substances, many of which are hazardous, (4) including metals (lead, cadmium, mercury, beryllium, indium, and so on), (5) flame retardants, (6) phthalates, and ozone depleting substances. The potential exists for employee exposure to these hazardous substances during recycling, but data are limited on the type and extent of exposures in developed countries.…”

Leaching capacity of metals–metalloids and recovery of valuable materials from waste LCDs

“…Furthermore, the implementation of a recycling program as a viable option should always include any potential adverse effects on human health. For instance, in some recycling plants in Sweden, significantly high concentrations of In, Cr, Co, Pb and Hg were measured in the blood and urine of employees that worked in the recycling units compared to the ones that worked in the offices (Julander et al, 2014). Furthermore, air pollution derived from As and Sb has been observed in the recycling facilities/plants of 13 villages in Guiyu, China (Bi et al, 2011).…”

Sistema mecánico abre bolsas: un ejemplo práctico para la enseñanza

“…Esto, debido a que hoy en día se ha incrementado el interés en la conservación del medio ambiente debido al alto índice de contaminación (Julander et al, 2014).…”