Effect of Alfalfa-Derived Biochar on Anaerobic Digestion of Dairy Manure

Abstract

Biochemical methane potential (BMP) tests were conducted for investigating the effects of alfalfa-derived biochar (AF-BC) on anaerobic digestion (AD) of dairy manure under various loading of AF-BC (0–10 g/L). BMP tests were performed at mesophilic temperature (37 °C) with the addition of AF-BC. Biogas and methane volumes and concentrations, water quality parameters (i.e., COD (chemical oxygen demand)), and volatile fatty acids (VFAs) were measured during the AD process. The addition of 1 and 5 g/L of AF-BC increased the biogas yields by 15.51% and 26.09% and methane yields by 14.61% and 26.88% compared with the control without addition of AF-BC. Additionally, the addition of AF-BC (1–10 g/L) decreased the lag phase by 7.14–22.45% and the CO2 content of biogas by 13.60–32.48%, while increasing the COD removal efficiency by 19.19–35.94% in the AD of dairy manure. Moreover, the addition of AF-BC also decreased total VFAs and acetic acid concentrations in the AD process. The increase in AD performance was mainly owing to the improvement of buffering ability of the AD system and direct interspecies electron transfer (DIET) among AD microorganisms resulting from the addition of AF-BC. In contrast, the addition of 10 g/L AF-BC did not show any obvious improvement in biogas and methane yields in the AD of dairy manure, possibly because of toxic effects from excessive addition of AF-BC toward the AD microorganisms. Therefore, this study supported practical feasibility of AF-BC-enhanced AD of dairy manure.

Dairy Manure-Derived Biochar in Soil Enhances Nutrient Metabolism and Soil Fertility, Altering the Soil Prokaryote Community

“…The nutrient-holding and releasing ability of BC can increase soil nutrient concentration. For instance, MBC had higher adsorption and release of ammonia, nitrate, and phosphate in water and soil than WBC [1,3,52,53]. This is not surprising, since dairy cattle are fed nutrient-rich diets to maintain high milk production and their manure contains significant amounts of excreted nutrients, particularly N and P [54,55].…”