Co-digestion of ruminal content and blood from slaughterhouse industries: influence of solid concentration and ammonium generation

Abstract

At the present time, organic solid wastes from industries and agricultural activities are considered to be promising substrates for biogas production via anaerobic digestion. Moreover solids stabilisation is required before reutilization or disposal. Slaughterhouses are among the most important industries in Uruguay and produce 150,000 tons of ruminal content (RC) and 30,000 tons of blood per year. In order to determine the influence of the solids and blood contents, the ammonia inhibition and the inoculum adaptation co-digestion batch tests were performed. A set of experiences with TS concentration of 2.5%, 5% and 7.5% and different ratios of RC/blood were carried out using an inoculum from an UASB reactor. In all experiences fast blood hydrolisation was observed. A higher methane production was detected in the experiences with higher TS content. However, the fraction of solids degradation was lower in these experiences. A plateau in the biogas production was found. The free ammonia level, which was above the reported inhibitory levels, could explain this behaviour. After the inhibition period the biogas production restarted probably due to the biomass acclimatisation to the ammonia. In order to determine the inoculum adaptation a new experiment was performed. The inoculum used was the sludge coming from the first set of experiences. Based upon batch tests a 3.5 m3 pilot reactor was designed and started up. Ammonia inhibition was avoided by the start-up strategy and in two weeks the biogas production was 3.5 m3/d. The VS stabilisation with a solid retention time of 20 days was of 43%. The pilot reactor working at steady state had a TS concentration of 3-4% with a ratio of RC/blood of 10:1 at the entrance.

Anaerobic Digestion of Blood from Slaughtered Livestock: A Review

“…Banks and Wang [99] observed almost the same inhibition in a continuous reactor digesting mixed swine and cattle manure and cattle blood (1 part by weight) and gut fill (3 parts gut fills by weight) with a similar methane yield of 0.17 m 3 kg −1 TS and 50% reduction in TS during 30 days of HRT. Lopez et al [97] co-digested poultry blood (10% dry weight basis) with ruminal content (90%) at TS of 3-4% and an HRT of 20 days and measured a biogas production rate of 1.0 m 3 biogas m −3 d −1 . It is evident that the previously discussed studies demonstrated that the AD of blood as a mono-substrate in the batch was successful in one study only [54], but with a low biogas yield (0.047 m 3 kg −1 VS).…”

Simultaneous Synergy in CH4 Yield and Kinetics: Criteria for Selecting the Best Mixtures during Co-Digestion of Wastewater and Manure from a Bovine Slaughterhouse

“…Similarly, previous studies have highlighted lignocellulosic as a suitable co-substrate for anaerobic digestion of blood. For instance, López et al (2006) [54] evaluated the AcoD of ruminal content and blood in batch digesters. The results showed an organic matter degradation from 55 to 70% when ruminal content/blood ratio (on a TS basis) varied between 2 and 8; the authors highlighted how during AcoD blood generates extra buffer capacity and brings micronutrients to the system.…”

Energy self-supply of large abattoir by sustainable waste utilization based on anaerobic mono-digestion

“…Some studies report on bio methane potential (BMP) of different waste fractions [10][11][12][13][14][15][16][17]. Besides that, continuous AD experiments at different process conditions (temperature, loading rate, influence of thermal pretreatment, NH 4 -removal) were conducted [11,[16][17][18][19][20][21][22].…”