The thermal performance of a single pass solar air heater with five fins attached was investigated experimentally. Longitudinal fins were used inferior the absorber plate to increase the heat exchange and render the flow fluid in the channel uniform. The effect of mass flow rate of air on the outlet temperature, the heat transfer in the thickness of the solar collector, and the thermal efficiency were studied. Experiments were performed for two air mass flow rates of 0.012 and 0.016 kg s−1. Moreover, the maximum efficiency values obtained for the 0.012 and 0.016 kg s−1 with and without fins were 40.02%, 51.50% and 34.92%, 43.94%, respectively. A comparison of the results of the mass flow rates by solar collector with and without fins shows a substantial enhancement in the thermal efficiency.
Abstract. This paper presents the study of heat transfer in a solar air heater by using new design of solar collector. The collector efficiency in a single pass of solar air heater without, and with using fins attached under the absorbing plate has been investigated experimentally. Due to adding the fins to the interior of an absorber plate, the desirable effect of increasing the heat transfer coefficient compensates for the undesirable effect of decreasing the driving force (temperature difference) of heat transfer, while the attached fins provide an enlarged heat transfer area. In this study, the absorbing plate of solar collector is attached with fins for further improved performance. The improvements of collector efficiencies in the single pass solar air heaters with, and without fins attached; increase with increasing the mass flow rate, especially for operating at lower air flow rate. Experiments were performed for two air mass flow rates of 0.012 and 0.016 kg/s. Moreover, the maximum efficiency obtained for the 0.012 and 0.016 kg/s with, and without fins were 40.02, 51.50% and 34.92, 43.94% respectively. A comparison of the results of the mass flow rates by solar collector with, and without fins shows a substantial enhancement in the thermal efficiency.
Transparent conducting Co doped ZnO thin films have been fabricated by Ultrasonic spray. The thin films were deposited at three different substrate temperatures of 300, 350 and 400 ı C. The obtained films had a hexagonal wurtzite structure with a strong (002) preferred orientation. The maximum crystallite size value of the film deposited at 350 ı C is 55.46 nm. Spectrophotometer (UV-vis) of a Co doped ZnO film deposited at 350 ı C shows an average transmittance of about 90%. The band gap energy increased from 3.351 to 3.362 eV when the substrate temperature increased from 300 to 350 ı C. The electrical conductivity of the films deposited at 300, 350 and 400 ı C were 7.424, 7.547 and 6.743 ( cm) 1 respectively. The maximum activation energy value of the films at 350 ı C was 1.28 eV, indicating that the films exhibit a n-type semiconducting nature.
This paper examines the growth of ZnO thin films on glass substrate at 350 ı C using an ultrasonic spray technique. We have investigated the influence of growth time ranging from 1 to 4 min on structural, optical and electrical properties of ZnO thin films. The as-grown films exhibit a hexagonal structure wurtzite and are (002) oriented. The maximum value of grain size G D 63.99 nm is attained for ZnO films grown at 2 min. The average transmittance is about 80%, thus the films are transparent in the visible region. The optical gap energy is found to increase from 3.26 to 3.37 eV with growth time increased from 1 to 2 min. The minimum value of electrical resistivity of the films is 0.13 cm obtained at 2 min. A systematic study on the influence of growth time on the properties of ZnO thin films deposited by ultrasonic spray at 350 ı C has been reported.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.