The survival of Salmonella typhimurium after a standard heat challenge at 55 degrees C for 25 min increased by several orders of magnitude when cells grown at 37 degrees C were pre-incubated at 42 degrees, 45 degrees or 48 degrees C before heating at the higher temperature. Heat resistance increased rapidly after the temperature shift, reaching near maximum levels within 30 min. Elevated heat resistance persisted for at least 10 h. Pre-incubation of cells at 48 degrees C for 30 min increased their resistance to subsequent heating at 50 degrees, 52 degrees, 55 degrees, 57 degrees or 59 degrees C. Survival curves of resistant cells were curvilinear. Estimated times for a '7D' inactivation increased by 2.6- to 20-fold compared with cells not pre-incubated before heat challenge.

The heat resistance of Salmonella typhimurium, measured as survival following a standard heat challenge at 55°C for 25 min, increased progressively as cells were heated up at linearly rising temperatures. The amount by which heat resistance increased depended on the rate of temperature rise; the slower the temperature rise, the greater the increase in resistance.

The duration of the lag phase of Salmonella typhimurium surviving heat, freezing, drying and gamma‐radiation was used to indicate the time needed to repair sublethal injury. Following equivalent lethal treatments, heat and freeze‐injured cells needed longer to repair than those injured by drying or gamma‐radiation. Measurement of repair on membrane filters showed that in a heat‐injured population having a lag time of 9 h, some individual cells needed up to 14 h to recover maximum tolerance to 3% NaCl.

The resistance of stationary phase Salmonella typhimurium to heating at 55 degrees C was greater in cells grown in nutritionally rich than in minimal media, but in all media tested resistance was enhanced by exposing cells to a primary heat shock at 48 degrees C. Chloramphenicol reduced the acquisition of thermotolerance in all media but did not completely prevent it in any. The onset of thermotolerance was accompanied by increased synthesis of major heat shock proteins of molecular weight about 83, 72, 64 and 25 kDa. When cells were shifted from 48 degrees C to 37 degrees C, however, thermotolerance was rapidly lost with no corresponding decrease in the levels of these proteins. There is thus no direct relationship between thermotolerance and the cellular content of the major heat shock proteins. One minor protein of molecular weight about 34 kDa disappeared rapidly following a temperature down-shift. Its presence in the cell was thus correlated with the thermotolerant state.

The resistance of Salmonella thompson to heating at 54° or 60°C in tryptone soya broth, liquid whole egg, 10% or 40% reconstituted dried milk or minced beef was increased if cells were held at 48°C for 30 min before heating at the higher temperatures. Induction of thermotolerance by mild heat shock is thus not confined to cells grown and heated in broth systems. The heat shock phenomenon may therefore have implications for the safety of foods given marginal heat treatment.