A number of reports have identified four volatile radionuclides that arise from the reprocessing of nuclear fuel ( 3 H, 14 C, 85 Kr, and 129 I) that require controls limiting their environmental release from reprocessing facilities in order to meet US regulatory requirements. Of these, 129 I has the longest half-life and highest potential biological impact.The study of inorganic iodide in aqueous reprocessing facility off-gas systems has been almost exclusively limited to I 2 , and the focus of organic iodide studies has been CH 3 I as a surrogate for various organic iodides that could be present. A study conducted in 2015 focused on those inorganic and organic iodine-bearing species in reprocessing plants that have the potential to be poorly sequestered with traditional capture methods. This study found that even if high decontamination factors (DFs) are achieved for the dissolver off-gas (DOG), losses of iodine to the head-end cell, if greater than about 0.1% of the total iodine inventory, can limit the overall plant DF unless sufficiently high DFs are also achieved for the cell off-gas. The same is true for the losses of iodine to the vessel off-gas (VOG), if those losses are greater than about 0.1%. The study further indicated that high DFs on the VOG may be difficult to achieve as it is the stream where penetrating, or difficult to remove, organic iodide species are most likely. These two factors prompted studies examining organic iodide removal from prototypic VOG streams at both Oak Ridge National Laboratory (ORNL) and Idaho National Laboratory (INL). These studies included an initial evaluation of reduced silver-exchanged mordenite (Ag 0 Z) and silver-functionalized silica-aerogel (AgAerogel) for the capture of CH 3 I and I 2 under VOG conditions by Jubin et al. (2017a) and for the capture of iodobutane under DOG conditions at INL (to be reported in 2018.)The objective of this report is to develop a robust experimental program that will evaluate the adsorption rate of long-chain organic iodides and identify any significant variations in mass transfer zone and byproducts produced during the adsorption on Ag 0 Z and AgAerogel under both DOG and VOG conditions expected for a used nuclear fuel aqueous reprocessing facility. Organic species of interest include both short-chain alkyl iodides such as methyl iodide (CH 3 I) and longer alkyl iodides up to iodododecane (C 10 H 21 I). The primary product of this report is a test plan for the experimental work that could be conducted as part of the ongoing off-gas abatement R&D efforts at both INL and at ORNL.
In fiscal year 2016 an Engineering Evaluation of an integrated off-gas system was conducted. This study resulted in a report entitled Engineering Evaluation of an Integrated Off-Gas Treatment System for Used Nuclear Fuel Reprocessing Facilities (Jubin et al. 2016a), from here referred to as the "Engineering Evaluation." This study focused on the capture and retention of the volatile radionuclides ( 3 H, 14 C, 85 Kr, and 129 I), selected semi-volatile radionuclides, specifically 106 Ru, and chemical species like NO and NO 2 generated during the dissolution of the used nuclear fuel. The study examined the design of the combined head-end off-gas streams and the vessel off-gas stream. The study drew upon the available literature to conduct the equipment sizing and sorbent usage. A number of assumptions were required to complete this analysis and major gaps in the available data were identified that, if resolved, could increase the fidelity of the engineering design.This assessment looks at those identified data gaps and the more subtle assumptions that were required in the Engineering Evaluation and provides a detailed look at the specific data needs for each major system. This assessment of the data gaps builds on a study conducted early in fiscal year 2016 that established a set of performance criteria for capture and immobilization technologies. The gaps identified in the engineering assessment also provided a check on the breadth of the criteria and metrics that were previously developed. During the analysis of the data gaps it was necessary to expand the metrics slightly to capture co-adsorption effects and to address desorption, neither of which were included in the original set of metrics. Across the six major off-gas control systems evaluated a number of common data gaps became apparent. These include: Capacity and adsorption rate data needs appear common for virtually all the unit operations considered. These two parameters dictate the dimensions and operating conditions of the sorbent beds and wet scrubber systems. The capacity dictates the mass and volume of Ru, tritium, I, and Kr/Xe sorbent beds for a given adsorption duration; the adsorption rate dictates the needed depth of the solid sorbent beds and the height of the wet scrubbers. Co-adsorption of other species is important to the extent that this interferes with the adsorption of the target species, impacts process operation, or impacts handling, recycle, or disposal of the spent sorbent/scrub solutions, and the waste form and disposal of the captured species. This is of secondary importance compared to demonstrating and optimizing capacity and adsorption rates for the target species; but co-adsorption and impacts of coadsorption are areas where generally even less is currently known for both sorbent beds and wet scrubber systems. Sorbent particle and bulk densities impact the volume of the adsorption system for a given mass of sorbent, but these physical properties data are readily measured. For systems including regenerable sorbents, data o...
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.