Seventeen Escherichia coli O157:H7 strains were treated with ultrahigh pressure at 500 MPa and 23 ؎ 2°C for 1 min. This treatment inactivated 0.6 to 3.4 log CFU/ml, depending on the strain. The diversity of these strains was confirmed by pulsed-field gel electrophoresis (PFGE) analysis, and there was no apparent association between PFGE banding patterns and pressure resistance. The pressure-resistant strain E. coli O157:H7 EC-88 (0.6-log decrease) and the pressure-sensitive strain ATCC 35150 (3.4-log decrease) were treated with a sublethal pressure (100 MPa for 15 min at 23 ؎ 2°C) and subjected to DNA microarray analysis using an E. coli K-12 antisense gene chip. High pressure affected the transcription of many genes involved in a variety of intracellular mechanisms of EC-88, including the stress response, the thiol-disulfide redox system, Fe-S cluster assembly, and spontaneous mutation. Twenty-four E. coli isogenic pairs with mutations in the genes regulated by the pressure treatment were treated with lethal pressures at 400 MPa and 23 ؎ 2°C for 5 min. The barotolerance of the mutants relative to that of the wild-type strains helped to explain the results obtained by DNA microarray analysis. This study is the first report to demonstrate that the expression of Fe-S cluster assembly proteins and the fumarate nitrate reductase regulator decreases the resistance to pressure, while sigma factor (RpoE), lipoprotein (NlpI), thioredoxin (TrxA), thioredoxin reductase (TrxB), a trehalose synthesis protein (OtsA), and a DNAbinding protein (Dps) promote barotolerance.

The activity of chymosin, plasmin, and Lactococcus lactis enzymes (cell envelope proteinase, intracellular peptidases, and glycolytic enzymes) were determined after 5-min exposures to pressures up to 800 MPa. Plasmin was unaffected by any pressure treatment. Chymosin activity was unaffected up to 400 MPa and decreased at 500 to 800 MPa. Fifty percent of control chymosin activity remained after the 800 MPa treatment. The lactococcal cell envelope proteinase (CEP) and intracellular peptidase activities were monitored in cell extracts of pressure-treated cells. A pressure of 100 MPa increased the CEP activity, whereas 200 MPa had no effect. At 300 MPa, CEP activity was reduced, and 400 to 800 MPa inactivated the enzyme. X-Prolyl-dipeptidyl aminopeptidase was insensitive to 5-min pressure treatments of 100 to 300 MPa, but was inactivated at 400 to 800 MPa. Aminopeptidase N was unaffected by 100 and 200 MPa. However, 300 MPa significantly reduced its activity, and 400 to 800 MPa inactivated it. Aminopeptidase C activity increased with increasing pressures up to 700 MPa. High pressure did not affect aminopeptidase A activity at any level. Hydrolysis of Lys-Ala-p-NA doubled after 300-MPa exposure, and was eliminated at 400 to 800 MPa. Glycolytic enzyme activities of pressure-treated cells were evaluated collectively by determining the titratable acidity as lactic acid produced by cell extracts in the presence of glucose. The titratable acidities produced by the 100 and 200 MPa samples were slightly increased compared to the control. At 300 to 800 MPa, no significant acid production was observed. These data demonstrate that high pressure causes no effect, activation, or inactivation of proteolytic and glycolytic enzymes depending on the pressure level and enzyme. Pressure treatment of cheese may alter enzymes involved in ripening, and pressure-treating L. lactis may provide a means to generate attenuated starters with altered enzyme profiles.

Viability, morphology, lysis, and cell wall hydrolase activity of Lactococcus lactis subsp. cremoris MG1363 and SK11 were determined after exposure to pressure. Both strains were completely inactivated at pressures of 400 to 800 MPa but unaffected at 100 and 200 MPa. At 300 MPa, the MG1363 and SK11 populations decreased by 7.3 and 2.5 log cycles, respectively. Transmission electron microscopy indicated that pressure caused intracellular and cell envelope damage. Pressure-treated MG1363 cell suspensions lysed more rapidly over time than did non-pressuretreated controls. Twenty-four hours after pressure treatment, the percent lysis ranged from 13.0 (0.1 MPa) to 43.3 (300 MPa). Analysis of the MG1363 supernatants by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) confirmed pressure-induced lysis. Pressure did not induce lysis or membrane permeability of SK11. Renaturing SDS-PAGE (zymogram analysis) revealed two hydrolytic bands from MG1363 cell extracts treated at all pressures (0.1 to 800 MPa). Measuring the reducing sugars released during enzymatic cell wall breakdown provided a quantitative, nondenaturing assay of cell wall hydrolase activity. Cells treated at 100 MPa released significantly more reducing sugar than other samples, including the non-pressure-treated control, indicating that pressure can activate cell wall hydrolase activity or increase cell wall accessibility to the enzyme. The cell suspensions treated at 200 and 300 MPa did not differ significantly from the control, whereas cells treated at pressures greater than 400 MPa displayed reduced cell wall hydrolase activity. These data suggest that high pressure can cause inactivation, physical damage, and lysis in L. lactis. Pressure-induced lysis is strain dependent and not solely dependent upon cell wall hydrolase activity.

Resistance of Escherichia coli O157 to inactivation by high-pressure processing, heat, and UV and gamma radiation was associated with the allele of the prophage-encoded antiterminator Q gene present upstream of the Shiga toxin gene stx2. Increased processing may be required to kill certain strains of E. coli O157, and the choice of strains used as surrogate markers for processing efficiency is critical.