Aqueous solutions of > or =5% glutaraldehyde (GA) are of moderate acute peroral toxicity and those of < or =2% are of slight toxicity. By single sustained skin contact, aqueous GA solutions of > or =45% are of moderate acute percutaneous toxicity, those of 25% are of slight toxicity and those of or =5%. Primary skin irritation depends on the duration and contact site, occlusion and solvent. By sustained contact, the threshold for skin irritation is 1%, above which erythema and edema are dose related. With 45% and higher, skin corrosion may occur. There is a low incidence of skin sensitizing reactions, with an eliciting threshold of 0.5% aqueous GA. However, GA is neither phototoxic nor photosensitizing. Subchronic repeated exposure studies by the peroral route show only renal physiological compensatory effects, secondary to reduced water consumption. Repeated skin contact shows only minor skin irritant effects without systemic toxicity. By subchronic vapor exposure, effects are limited to the nasal mucosa at 1.0 ppm, with a no-effect concentration generally at 0.1 ppm. There is no evidence for systemic target organ or tissue toxicity by subchronic repeated exposure by any route. A chronic drinking water study showed an apparent increase, in females only, of large granular cell lymphocytic leukemia but this was not dosage related. This is most likely the result of a modifying effect on the factor(s) responsible for the expression of this commonly occurring rat neoplasm. A chronic (2-year) inhalation toxicity/oncogenicity study showed inflammatory changes in the anterior nasal cavity but no neoplasms or systemic toxicity. In vitro genotoxicity studies--bacterial mutagenicity, forward gene mutation (HGPRT and TK loci), sister chromatid exchange, chromosome aberration, UDS and DNA repair tests--have given variable results, ranging from no effect through to weak positive. In vivo genotoxicity studies--micronucleus, chromosome aberration, dominant lethal and Drosophila tests--generally have shown no activity but one mouse intraperitoneal study showed bone marrow cell chromosome aberrations. Developmental toxicity studies show GA not to be teratogenic, and a two-generation study showed no adverse reproductive effects. Percutaneous pharmacokinetic studies showed low skin penetration, with lowest values measured in vitro in rats and human skin. Overexposure of humans produces typical sensory irritant effects on the eye, skin and respiratory tract. Some reports have described an asthmatic-like reaction by overexposure to GA vapor. In most cases this resembles reactive airways dysfunction s...
