Anaerobic digestion in wastewater reactors of separated organic fractions from wholesale markets waste. Compositional and batch characterization. Energy and environmental feasibility

Polo, Carlos Morales; Castro, María del Mar Cledera; Hueso-Kortekaas, Katia; Aramburu, Marta Revuelta

doi:10.1016/j.scitotenv.2020.138567

Cited by 19 publications

(10 citation statements)

References 44 publications

Supporting

Mentioning

Contrasting

Order By: Relevance

“…It was estimated in 2011 [2] that approximately 1728 million tons of FVW were produced per year worldwide, against 1.3 billion tons per year of food waste [3]. This waste is produced in the ultimate step of the food supply chain, relating to the unsold fresh products of the open market [4].…”

Section: Introductionmentioning

confidence: 99%

Assessment of Hydrogen and Volatile Fatty Acid Production from Fruit and Vegetable Waste: A Case Study of Mediterranean Markets

et al. 2022

View full text Add to dashboard Cite

This study investigates the dark fermentation of fruit and vegetable waste under mesophilic conditions (30–34 °C), as a valorization route for H2 and volatile fatty acids production, simulating the open market waste composition over the year in two Mediterranean countries. Specifically, the study focuses on the effect of the (i) seasonal variability, (ii) initial pH, and (iii) substrate/inoculum ratio on the yields and composition of the main end products. Concerning the seasonal variation, the summer and spring mixtures led to +16.8 and +21.7% higher H2 production than the winter/autumn mixture, respectively. Further investigation on the least productive substrate (winter/autumn) led to 193.0 ± 7.4 NmL of H2 g VS−1 at a pH of 5.5 and a substrate/inoculum of 1. With the same substrate, at a pH of 7.5, the highest acetic acid yield of 7.0 mmol/g VS was observed, with acetic acid corresponding to 78.2% of the total acids. Whereas a substrate/inoculum of 3 resulted in the lowest H2 yield, amounting to 111.2 ± 7.6 NmL of H2 g VS−1, due to a decrease of the pH to 4.8, which likely caused an inhibitory effect by undissociated acids. This study demonstrates that dark fermentation can be a valuable strategy to efficiently manage such leftovers, rather than landfilling or improperly treating them.

show abstract

Section: Introductionmentioning

confidence: 99%

Assessment of Hydrogen and Volatile Fatty Acid Production from Fruit and Vegetable Waste: A Case Study of Mediterranean Markets

et al. 2022

View full text Add to dashboard Cite

show abstract

“…In food supply chain another 40% food waste generated during the retail and consumer levels [3]. In Spain and, more broadly, Europe, the food industry is a major industrial sector and its generated waste is aerobically digested for biogas production [5]. In North America, including United States, Mexico, and Canada, an estimated food loss and waste was about 170 million tons.…”

Section: Introductionmentioning

confidence: 99%

Co-Fermentation of Food Waste and Municipal Sludge from the Saudi Arabian Environment to Improve Lactic Acid Production by Lactobacillus rhamnosus AW3 Isolated from Date Processing Waste

2020

View full text Add to dashboard Cite

Food waste and municipal sludge were used as the substrates for the biosynthesis of lactic acid in a batch fermentor. The probiotic bacterial strain Lactobacillus rhamnosus AW3 isolated from date processing waste was used to produce lactic acid in a batch fermentor. Co-fermentation enhanced the biosynthesis of lactic acid and decreased substrate inhibition more than mono-substrate fermentation. A maximum yield of 28.4 ± 0.87 g/L of lactic acid was obtained through co-fermentation of food waste and municipal sludge at an optimized ratio of 2:0.5. Lactic acid production was improved by the supplementation of fructose, peptone, and sodium dihydrogen phosphate at pH 5.5 after 48 h fermentation. This production was approximately three-fold higher than that during mono-fermentation of food waste. The tested bacterial strains were obtained from the Microbial Type Culture Collection (MTCC). Lactic acid showed potent antimicrobial activity against pathogenic organisms, such as Bacillus subtilis MTCC 5981 (14 mm), Staphylococcus aureus MTCC 737 (20 mm), Pseudomonas aeruginosa MTCC 424 (24 mm), Enterobacter aerogenes MTCC111 (19 mm), Escherichia coli MTCC 443 (18 mm), Penicillium chrysogenum MTCC 5108 (19 mm), and Aspergillus niger MTCC 282 (19 mm). The antimicrobial properties of lactic acid have significant potential to inhibit the growth of pathogenic bacteria and fungi and improve probiotic properties. The lactic acid extracted from L. rhamnosus AW3 decreased the pH value of soil (p < 0.01) and increased the availability of soil phosphorus (p < 0.01). These findings demonstrate the bioconversion of food waste and municipal sludge into lactic acid, and the recycling of food wastes in urban areas to enhance soil nutrients.

show abstract

“…In their study on the anaerobic digestion of four different fish wastes, the methane yield and final TAN content were 285 mL CH4 •g VS −1 and 728 mg•L −1 (both on average), respectively. Inhibition was signalized by Morales-Polo et al [29], where the anaerobic digestion of the anchovy waste generated only 4.6 mL CH4 •g VS −1 because of a distinct ammoniacal nitrogen accumulation (TAN concentration of 6.13 g•L −1 ).…”

Section: Resultsmentioning

confidence: 99%

“…Nges et al [27] and Bucker et al [28] measured a methane yield of 828 mL CH4 •g VS −1 and 540 mL CH4 •g VS −1 for salmon heads and carp viscera, respectively. When anchovy waste was used as starting substrate for anaerobic digestion, a very low methane yield was registered as a consequence of the excessive accumulation of ammonia [29]. In general, the production of methane, through AD processes, ranges from 200 to 900 mL CH4 •g VS −1 , depending on the nature of the fish waste [30].…”

Section: Introductionmentioning

confidence: 99%

Towards the Anchovy Biorefinery: Biogas Production from Anchovy Processing Waste after Fish Oil Extraction with Biobased Limonene

et al. 2021

View full text Add to dashboard Cite

Anchovies are among the largest fish catch worldwide. The anchovy fillet industry generates a huge amount of biowaste (e.g., fish heads, bones, tails) that can be used for the extraction of several potentially valuable bioproducts including omega-3 lipids. Following the extraction of valued fish oil rich in omega-3, vitamin D3 and zeaxanthin from anchovy fillet leftovers using biobased limonene in a fully circular process, the solid residue (anchovy sludge) was used as starting substrate for the production of biogas by anaerobic digestion. In spite of the unbalanced carbon to nitrogen (C/N) ratio, typical of marine biowaste, the anchovy sludge showed a good methane yield (about 280 mLCH4∙gVS−1), proving to be an ideal substrate for co-digestion along with other carbon rich wastes and residues. Furthermore, the presence of residual limonene, used as a renewable, not-toxic and edible extraction solvent, does not affect the microbial methanogenesis. The results reported in this study demonstrate that anchovy leftovers after the fish oil extraction process can be efficiently used as a starting co-substrate for the production of biogas in a modern biorefinery.

show abstract

Anaerobic digestion in wastewater reactors of separated organic fractions from wholesale markets waste. Compositional and batch characterization. Energy and environmental feasibility

Cited by 19 publications

References 44 publications

Assessment of Hydrogen and Volatile Fatty Acid Production from Fruit and Vegetable Waste: A Case Study of Mediterranean Markets

Assessment of Hydrogen and Volatile Fatty Acid Production from Fruit and Vegetable Waste: A Case Study of Mediterranean Markets

Co-Fermentation of Food Waste and Municipal Sludge from the Saudi Arabian Environment to Improve Lactic Acid Production by Lactobacillus rhamnosus AW3 Isolated from Date Processing Waste

Towards the Anchovy Biorefinery: Biogas Production from Anchovy Processing Waste after Fish Oil Extraction with Biobased Limonene

Contact Info

Product

Resources

About