The objective of this research was to investigate the fermentation performance of waxy grain sorghum for ethanol production. Twenty‐five waxy grain sorghum varieties were evaluated with a laboratory dry‐grind procedure. Total starch and amylose contents were measured following colorimetric procedures. Total starch and amylose contents ranged from 65.4 to 76.3% and from 5.5 to 7.3%, respectively. Fermentation efficiencies were in the range of 86.0–92.2%, corresponding to ethanol yields of 2.61–3.03 gallons/bushel. The advantages of using waxy sorghums for ethanol production include easier gelatinization and low viscosity during liquefaction, higher starch and protein digestibility, higher free amino nitrogen (FAN) content, and shorter fermentation times. The results showed a strong linear relationship between FAN content and fermentation rate. Fermentation rate increased as FAN content increased, especially during the first 30 hr of fermentation (R2 = 0.90). Total starch content in distillers dried grains with solubles (DDGS) was less than 1% for all waxy varieties.

This study was carried out to investigate the chemical and rheological properties of different blends prepared using hard white winter wheat (HWWW; Triticum aestivum Desf.) and whole or decorticated sorghum (Sorghum bicolor). Whole and decorticated sorghum were used to replace 5, 10, 15 and 20% of wheat flour. Wheat samples had higher protein, moisture and calcium values and lower fat, ash, carbohydrates, iron and phosphorous values compared to whole and decorticated sorghum flours. Decortication of sorghum grains decreased moisture, ash, fat, crude protein, iron and phosphorous content, but increased carbohydrate content. Farinogram properties such as dough water absorption, development time and stability and Farinograph quality number decreased as the amount of substituted sorghum increased; whereas mixing tolerance index increased. Moreover, at fixed gluten levels, as sorghum flour increased in the blend, wet gluten, dry gluten and gluten index decreased. Increasing sorghum in the blend also decreased energy, resistance to extension and extensibility of the dough, but contributed to an increase in the ratio of resistance to extensibility. Furthermore, as fermentation time increased, energy, resistance to extension and the ratio number of energy to extension increased, whereas extensibility decreased.

Quality and agronomic effects of three transgenic high molecular weight glutenin subunit (HMW‐GS) events were characterized in advanced‐generation breeding lines of hard winter wheat (Triticum aestivum L.) in three Nebraska crop years. Two of the transgenic events studied, Dy10‐E and B52a‐6, overexpress HMW‐GS 1Dy10, while the third event, Dx5 +Dy10‐H, overexpresses HMW‐GS 1Dx5 and, to a much lesser extent, 1Dy10. In addition, novel proteins possessing solubility characteristics defined as HMW‐GS were present in Dx5+Dy10‐H and B52a‐6. Average grain yield of lines derived from the three transgenic events was statistically lower than that of a group of control cultivars and advanced breeding lines, but not lower than the mean values of respective nontransgenic siblings. Grain hardness was influenced by one of the events. Dx5+Dy10‐H produced harder kernels than controls, its nontransgenic siblings, and the two additional transgenic events. All three events produced doughs with unusual mixing properties, although not likely to be directly useful in commercial applications. As a consequence, loaf volumes were depressed to variable degrees by the three events. The results indicated that over‐expression of HMW‐GS could eventually lead to improved breadmaking quality by optimizing the level of overexpression or by development and characterization of additional events.

Dough strength is needed for efficient breadmaking quality. This property is strongly influenced in wheat (Triticum aestivum L.) by gluten seed storage proteins and, in particular, by high‐molecular‐weight (HMW) glutenin subunit composition. Experiments were designed to elevate expression of a key native HMW glutenin subunit (1Dy10) via genetic engineering and to determine whether resultant flours can be used in sponge and dough applications, the most common commercial bread‐baking procedure. Both unblended and blended samples from transgenic and nontransgenic sister lines were tested, with blended samples being formed by addition to a control sample. Dough properties, as determined by farinograph evaluation, were improved by the transgene‐encoded increases in 1Dy10 in both undiluted and blended flours. Mean farinograph stability of transgenic samples was twice that of the control, and blends with transgenic samples demonstrated increases in stabilities proportional to the amount of transgenic flour included. Mean farinograph quality numbers of transgenic samples, and of all blends containing transgenic flour, were significantly higher than both the control and all nontransgenic treatments. In the sponge and dough bake procedure, undiluted transgenic samples induced lower scores, relative to both control and undiluted nontransgenic samples, for water absorption, crumb body firmness, and loaf volume. In blends, however, the transgenic samples resulted in improvements in some sponge and dough loaf attributes, including loaf symmetry and crumb color score, without any concomitant loss of loaf volume in transgenic blends. These improved variables relate to finished product appearance and to consumer selection in markets. The use of transgenic flours with increased 1Dy10 glutenin content in commercial blends could provide advantages in sponge and dough bake applications.