Efforts to recycle organic wastes using black soldier fly (BSF) Hermetia illucens into high-nutrient biomass that constitutes a sustainable fat (biodiesel) and high-quality protein ingredient in animal feeds have recently gained momentum worldwide. However, there is little information on the most suitable rearing conditions for growth, development and survivorship of these flies, which is a prerequisite for mass production technologies. We evaluated the physiological requirements for growth and reproduction of H. illucens on two diets [spent grains supplemented with brewers’ yeast (D1) and un-supplemented (D2)]. Development rates at nine constant temperatures (10–42°C) were fitted to temperature-dependent linear and non-linear day-degree models. Thereafter, life history table parameters were determined within a range of favourable temperatures. The thermal maximum (TM) estimates for larval, pre-pupal and pupal development using non-linear model ranged between 37.2 ± 0.3 and 44.0 ± 2.3°C. The non-linear and linear day-degree model estimations of lower developmental temperature threshold for larvae were 11.7 ± 0.9 and 12.3 ± 1.4°C for D1, and 10.4 ± 1.7 and 11.7 ± 3.0°C for D2, respectively. The estimated thermal constant of immature life stages development of BSF was higher for the larval stage (250±25 DD for D1 and 333±51 for D2) than the other stages evaluated. Final larval wet weight was higher on D1 compared to D2. The population growth rate was most favourable at 30-degree celsius (°C) with higher intrinsic rate of natural increase (rm = 0.127 for D1 and 0.122 for D2) and shorter doubling time (5.5 days for D1 and 5.7 days for D2) compared to the other temperatures. These results are valuable for the optimization of commercial mass rearing procedures of BSF under various environmental conditions and prediction of population dynamics patterns using computer simulation models.

No abstract

Simple SummaryPig keeping is an important source of income but the high cost of fishmeal (FM), which is the main protein source in animal feeds, has hindered the sector from realizing its full potential. As an alternative, we investigated the suitability of a meal derived from black soldier fly larvae (BSFLM) as a protein source. Pigs were fed different diet types: Control (no BSFLM: 0% (T0)), 25% (T25), 50% (T50), 75% (T75) and 100% (T100) replacement of FM by BSFLM. Average daily feed intake, body weight gain and feed conversion ratio were not affected by the replacement of FM by BSFLM. Red or white blood cell parameters did not differ among diets, except for neutrophil counts, which were higher at T75 and T100 compared to T0. At T25, T75 and T100, pigs had lower platelet counts compared to pigs fed T0 and T50. Dietary BSFLM inclusion did not influence blood cholesterol levels. The cost–benefit ratio and return on investment were similar across diets. Our study shows that BSFLM is a suitable and cost-effective alternative to FM in pig feeds.AbstractPig production is one of the fastest growing livestock sectors. Development of this sector is hampered by rapidly increasing costs of fishmeal (FM), which is a common protein source in animal feeds. Here, we explored the potential of substituting FM with black soldier fly larval meal (BSFLM) on growth and blood parameters of pigs as well as economic aspects. At weaning, 40 hybrid pigs, i.e., crossbreeds of purebred Large White and Landrace were randomly assigned to five iso-nitrogenous and iso-energetic dietary treatments: Control (0% BSFLM and 100% FM (T0)), and FM replaced at 25% (T25), 50% (T50), 75% (T75) and 100% (T100) with BSFLM. Average daily feed intake (ADFI), average daily gain (ADG), body weight gain (BWG) and feed conversion ratio (FCR) were calculated for the whole trial. Hematological and serum biochemical parameters, the cost–benefit ratio (CBR) and return on investment (RoI) were evaluated. No significant effect of diet type was observed on feed intake and daily weight gain. Red or white blood cell indices did not differ among diets. Pigs fed T25, T75 and T100, had lower platelet counts compared to T0 and T50. Dietary inclusion of BSFLM did not affect blood total cholesterol, triglycerides, low-density lipoprotein and high-density lipoprotein. CBR and RoI were similar for the various diets. In conclusion, BSFLM is a suitable and cost-effective alternative to fishmeal in feed for growing pigs.