The effect of a range of milk heat treatments on the rheological properties, at small and large deformations, of acid skim milk gels was investigated. Gels were made from reconstituted skim milk heated at 75, 80, 85 and 90°C for 15 or 30 min by acidification with glucono-δ-lactone at 30°C. Gels were also made from skim milk powder (SMP) samples that had been given a range of preheat treatments during powder manufacture. Heating milks at temperatures [ges ]80°C for 15 min increased the storage moduli (G′) compared with unheated milk and produced gels with G′ in the range 300–450 Pa. Acid gels made from high-heat or medium-heat SMP had higher G′ than gels made from low-heat or ultra-low-heat SMP. Cooling gels to low temperatures resulted in an increase in G′. The yield stress of gels slightly decreased with mild heat treatments of milk, and then increased again to a maximum, finally decreasing slightly with very high heat treatments of milk. The strain at yielding decreased markedly with increasing heat treatment of milk, making these gels brittle and easier to fracture. We propose that denatured whey proteins aggregated with casein particles during the acidification of heated milk and were responsible for most of the effects observed in this study.

No abstract

The effect of interactions of denatured whey proteins with casein micelles on the rheological properties of acid milk gels was investigated. Gels were made by acidification of skim milk with glucono-δ-lactone at 30°C using reconstituted skim milk powders (SMP; both low- and ultra-low-heat) and fresh skim milk (FSM). The final pH of the gels was ∼4·6. Milks containing associated or ‘bound’ denatured whey proteins (BDWP) with casein micelles were made by resuspending the ultracentrifugal pellet of heated milk in ultrafiltration permeate. Milks containing ‘soluble’ denatured whey protein (SDWP) aggregates were formed by heat treatment of an ultracentrifugal supernatant which was then resuspended with the pellet. Acid gels made from unheated milks had low storage moduli, G′, of <20 Pa. Heating milks at 80°C for 30 min resulted in acid gels with G′ in the range 390–430 Pa. The loss tangent (tan δ) of gels made from heated milk increased after gelation to attain a maximum at pH ∼5·1, but no maximum was observed in gels made from unheated milk. Acid gels made from milks containing BDWP that were made from low-heat SMP, ultra-low-heat SMP and FSM had G′ of about 250, 270 and 310 Pa respectively. Acid gels made from milks containing SDWP that were made from ultra-low-heat SMP or FSM had G′ values in the range 17–30 Pa, but gels made from low-heat SMP had G′ of ∼140 Pa. It was concluded that BDWP were important for the increased G′ of acid gels made from heated milk. Addition of N-ethylmaleimide (NEM) to low-heat reconstituted milk, to block the —SH groups, resulted in a reduction of the G′ of gels formed from heated milk but did not reduce G′ to the value of unheated milk. Addition of 20 mm-NEM to FSM, prior to heat treatment, resulted in gels with a lower G′ value than gels made from reconstituted low-heat SMP. It was suggested that small amounts of denatured whey proteins associated with casein micelles during low-heat SMP manufacture were probably responsible for the higher G′ of gels made from milk containing SDWP and from milk heated in the presence of 20 mm-NEM, compared with gels made from FSM.

No abstract

No abstract