The citrus-processing industry generates in the Mediterranean area huge amounts of orange peel as a byproduct from the industrial extraction of citrus juices. To reduce its environmental impact as well as to provide an extra profit, this residue was investigated in this study as an alternative substrate for the fermentative production of citric acid. Orange peel contained 16.9% soluble sugars, 9.21% cellulose, 10.5% hemicellulose, and 42.5% pectin as the most important components. To get solutions rich in soluble and starchy sugars to be used as a carbon source for citric acid fermentation, this raw material was submitted to autohydrolysis, a process that does not make use of any acidic catalyst. Liquors obtained by this process under optimum conditions (temperature of 130 degrees C and a liquid/solid ratio of 8.0 g/g) contained 38.2 g/L free sugars (8.3 g/L sucrose, 13.7 g/L glucose, and 16.2 g/L fructose) and significant amounts of metals, particularly Mg, Ca, Zn, and K. Without additional nutrients, these liquors were employed for citric acid production by Aspergillus niger CECT 2090 (ATCC 9142, NRRL 599). Addition of calcium carbonate enhanced citric acid production because it prevented progressive acidification of the medium. Moreover, the influence of methanol addition on citric acid formation was investigated. Under the best conditions (40 mL of methanol/kg of medium), an effective conversion of sugars into citric acid was ensured (maximum citric acid concentration of 9.2 g/L, volumetric productivity of 0.128 g/(L.h), and yield of product on consumed sugars of 0.53 g/g), hence demonstrating the potential of orange peel wastes as an alternative raw material for citric acid fermentation.
Hydrolysates obtained by autohydrolysis-posthydrolysis of corncobs were detoxified with charcoal, concentrated, supplemented with nutrients, and fermented with Debaryomyces hansenii. After biomass removal, the fermented media contained 0.1137 kg of nonvolatile components (NVC)/kg of liquor, which corresponded mainly to xylitol (0.6249 kg/kg of NVC) but also to minor amounts of inorganic components (measured as ashes), proteins, nonfermented sugars (xylose and arabinose), uronic acids, arabitol, and other nonvolatile components (ONVC). The media were subjected to further processing (sequential stages of adsorption, concentration, ethanol precipitation, concentration, and crystallization) to obtain food-grade xylitol. Adsorption experiments were carried out at various solid-to-liquor ratios. Under selected conditions (1 kg of charcoal/15 kg of liquors), the xylitol content increased to 0.6873 kg/kg of NVC, and almost total decoloration was achieved. The resulting liquor was concentrated by evaporation to increase its NVC content to 0.4032 kg/kg of liquor (corresponding to a xylitol concentration of 0.280 kg/kg of liquor), and ethanol was added to precipitate a part of the NVC (mainly proteins, but also uronic acids, ashes, and other nonvolatile compounds). Refined liquors (containing 0.7303 kg of xylitol/kg of NVC) were concentrated again, and ethanol was added (to reach 40-60% volume of the stream) to allow crystallization at -10 or -5 degrees C. Under selected conditions, 43.7% of xylitol contained in the initial fermentation broth was recovered in well-formed, homogeneous crystals, in which xylitol accounted for 98.9% of the total oven-dry weight. Material balances are presented for the whole processing scheme considered in this work.
The cyanobacterium Spirulina platensis was cultivated in bench-scale miniponds on bicarbonate/carbonate solutions using urea as nitrogen source. To minimize limitation and inhibition phenomena, urea was supplied semicontinuously using exponentially increasing feeding rates. The average growth rates obtained alternately varying the total mass of urea added per unit reactor volume (275 < mT < 725 mg/L) and the total feeding time (9 < tT < 15 d) clearly evidenced nitrogen limitation for mT< 500 mg/L and excess nitrogen inhibition above this threshold. The time behavior of the specific growth rate at variable urea feeding patterns allowed estimation of the time-dependent Gibbs energy dissipation for cell growth under the actual depletion conditions of fed-batch cultivations. Comparison of the yield of growth on Gibbs energy obtained using either urea or KNO3 pointed to the preference of S. platensis for the former nitrogen source, likely owing to more favorable bioenergetic conditions.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.