We conducted three experiments to determine the apparent ileal digestibility of amino acids (Exp. 1), metabolizable and digestible energy (Exp. 2), and feeding value (Exp. 3) of dry extruded-expelled soybean meal with (DEH) or without (DENH) hulls compared with solvent-extracted soybean meal with hulls removed (SBMNH). Soybeans used to produce DEH were unadulterated prior to extrusion, but those used for DENH were dehulled prior to extrusion. In Exp. 1, six nonlittermate barrows (initially 39 kg) were fitted with ileal T-cannulas and used in a replicated 3 x 3 Latin square design digestion trial. Experimental diets (0.80% total lysine) were cornstarch-based and contained soybean meal from one of the three different sources as the sole source of lysine. Apparent ileal digestibilies of nutrients were similar (P > 0.10) for DEH and DENH. Apparent ileal digestibilies of CP, Lys, Ile, Leu, Arg, Phe, and Val were greater (P < 0.05) for DEH and DENH than for SBMNH. In Exp. 2, six barrows (initially 41 kg) were fed three corn-based diets containing 25% of one of the three soybean meal sources. A fourth diet was fed at the end of the trial containing all ingredients except soybean meal, so that energy values of the soybean meal could be determined by difference. Digestible energy and ME contents were similar (P > 0.10) for DEH and DENH and both had greater (P < 0.05) DE and ME contents than SBMNH. In Exp. 3, pigs (n = 216, initially 10.6 +/- 1.3 kg and 35 +/- 3 d of age) were blocked by weight and allotted to six dietary treatments. Corn-soybean meal-based diets (0.95% digestible lysine and 3.44 kcal/g ME) containing DEH or DENH were compared with similar diets containing SBMNH or solvent-extracted soybean meal with hulls (SBMH). In addition, a diet containing a second expelled soybean meal with hulls (ESBM) was compared with a diet containing SBMH and soy oil. Growth performance of pigs fed diets containing DEH or DENH was not different (P > 0.10) than that of pigs fed corresponding diets containing SMBH or SBMNH. Pigs fed ESBM had lower (P < 0.05) ADG and G/F compared with its corresponding SBMH and soy oil diet. In conclusion, DEH and DENH are more digestible than conventional soybean meal and can be successfully used in swine diets.

An experiment was conducted to study the influence of dietary total phosphorus (TP) level and source on the performance of two strains of commercial layers for two consecutive production years (26 to 68 and 76 to 116 weeks of age, respectively). Diet 1 contained .4% TP; Diets 2, 3 and 4 contained .5, .6, and .7% TP with supplemental P from dicalcium phosphate (DCP); Diets 5 and 6 contained .5 and .6% TP, respectively, with supplemental P from a sample of raw rock phosphate (RRP-1); Diets 7 and 8 contained .5 and .6% TP, respectively, with supplemental P from a second sample of raw rock phosphate (RRP-2). Calcium level was 2.75% in all diets, and crushed oyster shell provided ad libitum to all birds increased the total calcium to about 3.00%. Diet 1 was inferior to the average of all supplemented diets relative to feed consumption rate (P less than .005) and egg weight (P less than .005) during the first year. Diet 1 was also inferior relative to egg production rate (P less than .01), feed consumption rate (P less than .005), and egg weight (P less than .005) during the second year, whereas it was superior in shell quality (P less than .05) during the first year. Increasing TP from DCP resulted in a significant linear increase in feed consumption (P less than .05), feed conversion ratio, and Haugh units (P less than .005). Increasing TP from DCP also resulted in a significant linear decrease in shell quality (P less than .05) and significant linear and quadratic decreases in egg weight (P less than .005) during the first year. During the second year, increasing TP from DCP resulted in a significant linear decrease in egg production rate (P less than .005) and feed efficiency but significant linear (P less than .01) and quadratic (P less than .05) increases in feed consumption, and significant linear and quadratic increases (P less than .005) in Haugh units. Hens receiving RRP diets responded differently during the first and second years. The DCP supported greater egg weight than the RRP during the second year and permitted better feed conversion during both years. Strain A produced larger eggs than Strain B regardless of treatment (P less than .005). When egg production rate and most other response criteria were considered, .5% TP with DCP as the supplemental source gave the best results in both production years. A TP of .6% from RRP-2 gave similar results in both years.

We conducted two experiments comparing the use of extruded-expelled soybean meal (EESoy) to solvent-extracted soybean meal (SBM) in swine diets. In Exp. 1, the objective was to determine the optimal processing temperature of EESoy for nursery pig growth performance. Pigs (n = 330, 13.2 +/- 2.3 kg of BW) were fed a control diet containing SBM with added fat or one of five diets containing EESoy extruded at 143.3, 148.9, 154.4, 160.0, or 165.6 degrees C. All diets were formulated on an equal apparent digestible lysine:ME ratio. From d 0 to 20, no differences were observed (P > 0.32) in ADG or ADFI (average of 544 and 924 g/d, respectively). However, gain:feed ratio (G/F) improved (quadratic, P < 0.01, range of 0.56 to 0.60) with increasing processing temperature, with the greatest improvement at 148.9 degrees C. In Exp. 2, the objective was to determine the feeding value of EESoy relative to SBM with or without added fat for growing-finishing pigs in a commercial production facility. A total of 1,200 gilts (initially 24.5 +/- 5.1 kg of BW) was used, with 25 pigs per pen and eight replications per treatment. Dietary treatments were arranged in a 2 x 3 factorial, with two sources of soybean meal (SBM or EESoy) and three levels of added fat. Pigs were phase-fed four diets over the experimental period and added fat (choice white grease) levels were 0, 3.4, and 7% initially, with the added fat levels decreasing in the next three dietary phases. Energy levels were based such that the higher energy in EESoy (with or without added fat) was calculated to be equal to that provided by SBM with added fat. From 24.5 to 61.2 kg, pigs fed EESoy had greater (P < 0.07) G/F than those fed SBM. Increasing added fat in either EESoy- or SBM-based diets increased G/F (linear, P < 0.0003). From 61.2 to 122.5 kg, ADG and G/F were unaffected in pigs fed EESoy and/or increasing added fat (P > 0.10). For the overall growing-finishing period, ADG was unaffected (P > 0.61) by increasing energy density of the diet; however, ADFI decreased (P < 0.05) and G/F increased (P < 0.02, range of 0.37 to 0.40) as energy density increased with either EESoy or added fat. Carcass leanness was not affected by dietary treatment. These results indicate that EESoy should be extruded at 148.9 to 154.4 degrees C, and that increasing dietary energy density by using EESoy and/or added fat improves feed efficiency in finishing pigs reared in a commercial environment.

No abstract

A low-sodium diet (.08% Na) was used to force molt 409 hens. Another 421 hens were force molted by conventional water and feed restrictions. Birds were 68 weeks of age at that time, and two strains were about equally represented in each treatment group. These strains were: A, DeKalb; and B, Hisex. The low-sodium diet and water were provided ad libitum to the first group for the entire period of molt (42 days). The second group received no water for 3 days, and no feed for 4 days, after which incremental amounts of whole oats were provided as the only feed until Day 18. After Day 18, incremental amounts of a regular laying mash and decremental amounts of whole oats were provided through Day 26, when laying mash only was given ad libitum. Both treatment groups were in the same building and received the same lighting program during the force-molt period. This program consisted of: Days 1 to 3, no light; Days 4 to 18, 8 hr/day; Days 19 to 25, 9 hr/day; Day 26, 10 hr; then, light was increased 30 min weekly until 14 hr daily was attained. The low-sodium group ceased laying after 28 to 31 days, lost 8.7% of their premolt body weight, reduced feed consumption by 35%, and decreased egg production from 62.3% (in the 28 days preceding the molt) to 19% in the 42 days of molt; their mortality rate was 3.4%.(ABSTRACT TRUNCATED AT 250 WORDS)