Interest in phenolic compounds has recently increased due to their potential as antioxidant agents. Moringa leaves (Moringa oleifera) have a high content of phenolic compounds, which presents them as a promising source for the extraction of these compounds. However, it is necessary to use analytical techniques to identify and quantify their actual compound content to determine the quality of the raw material and the potential of the final product. Ultrasound assisted extraction is a green, rapid and environmentally friendly extraction technique that produces high quality extracts from natural products. Hence, the aim of this research is to optimize the variables of the ultrasound-assisted extraction (UAE) process for the extraction of moringa leaves using response surface methodology (RSM) to extract the main flavonoids using methanol as the extraction solvent. A Box–Behnken design (BBD) has been used to evaluate the effect of the ultrasound extraction process variables. Finally, the optimal extraction time in the range between 2 and 30 min was determined. The results revealed that the methanol concentration was the most influential variable. The optimal extraction time was established at 15 min. Six of the main flavonoids were quantified by UHPLC-DAD and identified by UHPLC-QToF-MS. The results confirmed that UAE is an efficient method for the extraction and subsequent analysis and quality control of the flavonoids that can be found in moringa leaves.

Supercritical fluid extraction (SFE), using CO2, is a novel, sustainable and very efficient technique for the recovery of highly apolar compounds. However, the recovery of phenolic compounds requires the use of different co-solvent combinations such as water and ethanol to enhance the recovery of these compounds through the optimization of a number of variables. In this sense, the effect of pressure (100, 150 and 200 bar), temperature (50, 65 and 80 °C), extraction time (30, 60, 90, 120, 150 and 180 min) and the effect of the different percentages of ethanol and water as co-solvents on the composition and phenolic content of moringa leaf extracts were evaluated. Six major flavonoids were identified by ultra-high-performance liquid chromatography coupled to a quadrupole-time-of-flight mass spectrometer (UHPLC-Q-ToF-MS). Pressure and temperature had a significant effect on the phenolic composition of the extracts, as well as on their concentrations. The highest concentration of total flavonoids compounds (TFCs) was obtained by using a mixture of CO2 and water of 50:50 (v/v) at 100 bar, at 65 °C after a 120 min extraction time that produced a concentration of 11.66 mg ± 0.02 mg TFC g−1 sample, which corresponds to 89.0% of the total flavonoids of the sample, obtained by exhaustive extraction.