Cereal Chem. 85(6):792-798The aim was to study the dual effect of sorghum decortication and protease treatment before liquefaction with α-amylase on the performance of subsequent steps of saccharification and fermentation. A bifactorial experiment with a level of confidence of P < 0.05 was designed to study differences among grains (maize, whole, and decorticated sorghum) and the effectiveness of the protease before liquefaction. Sorghum was decorticated to remove most of the pericarp and part of the germ and increase starch concentration of the feedstock. The decorticated sorghum had significantly higher starch hydrolysis during liquefaction compared with the whole kernel. These hydrolyzates contained ≈50% more reducing sugars than the untreated counterparts. At the end of saccharification, the final glucose concentration in hydrolyzates treated without protease was the highest for maize (180 mg/mL), followed by decorticated sorghum (165 mg/mL), and whole sorghum (145 mg/mL). Decortication and protease treatment had a significant effect on fermentation times. In decorticated sorghum mash treated with and without protease, fermentation times were 22 and 60 hr, respectively. The decorticated sorghum treated with protease yielded similar amounts of ethanol compared with maize and 44% more ethanol compared with the untreated whole sorghum. Both sorghum decortication and protease treatments before hydrolysis with αamylase are recommended to increase ethanol yields, lower yields of distilled grains, and save liquefaction, saccharification, and fermentation times.
The efficiency of ethanol fermentation, as affected by grain source (maize and decorticated red sorghum), total sugar concentration (13 or 20° Plato) and type of microorganism (Saccharomyces cerevisiae or Zymomonas mobilis) was studied. Maize mashes yielded 0.32 l ethanol kg(-1) ground grain whereas mashes prepared with decorticated red sorghum produced 0.28 l ethanol kg(-1). Both microorganisms yielded similar amounts of ethanol. However, high-gravity mashes (20° Plato) yielded lower amounts of ethanol compared to counterparts adjusted to 13° Plato (0.28 vs. 0.22 l ethanol kg(-1) ground grains). In decorticated sorghum mashes adjusted to 20° P, Z. mobilis produced 40 ml kg(-1) more ethanol compared to S. cerevisiae. In addition, Z. mobilis had a lower dependency on nitrogenous compounds.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.