Rcebido em 26/7/07; aceito em 14/11/07; publicado na web em 8/7/08 IMMOBILIZATION OF IRON (II) IN ALGINATE MATRIX AND ITS USE IN TEXTILE DYE DEGRADATION BY FENTONPROCESSES. In this work Fenton and photo-Fenton processes for textile dye degradation were investigated using iron (II) immobilized in alginate spheres. Photomicrographs obtained by scanning electron microscopy showed an irregular and porous surface with a homogeneous distribution of iron. The Fenton process was used to evaluate the degradation efficiency of reactive dyes and this procedure showed a low degradation effect. The association of artificial visible light or solar radiation in the Fenton process (foto-Fenton process) showed degradation ratios of 70 and 80% respectively in 45 min. It was also observed that the ironalginate matrix can be reused.Keywords: Fenton process; immobilized iron; alginate. INTRODUÇÃODentro do contexto do controle da poluição ambiental, a eliminação de substâncias químicas tóxicas presentes nos efluentes de produção se apresenta como um dos fatores mais importantes, o que faz com que o estudo de alternativas de tratamento eficientes e de baixo custo seja uma premente necessidade.Dentre as várias fontes de contaminação dos recursos hídricos é possível destacar o setor industrial, em razão do elevado consumo de água e da conseqüente geração de grandes volumes de resí-duos.1 Dentro deste contexto, as indústrias têxteis ocupam um lugar de destaque, uma vez que, dependendo do processo e do equipamento utilizado, da qualidade do produto final e do tipo de fibra beneficiada, o consumo de água alcança valores entre 25 e 250 m 3 por tonelada de produto. 2,3Uma das grandes dificuldades enfrentadas por este tipo de indústria está centrada no controle e na remoção de corantes presentes nas águas residuárias.Além de provocar problemas estéticos, a descarga de corantes em corpos aquáticos pode causar importante impacto ambiental, principalmente em função da sua interferência nos processos fotossintéticos naturais.4-6 A maior preocupação, entretanto, está relacionada com a descarga de resíduos contendo corantes azo, os quais podem ser biotransformados no ambiente, gerando produtos de elevado poder carcinogênico e mutagênico. 4 Pelos motivos antes salientados, o tratamento de resíduos aquosos contendo corantes deve ser encarado como prioridade. Infelizmente, grande parte das rotinas de tratamento utilizadas pela indústria apresenta eficiência reduzida, 4,7 o que faz com que o estudo de novas alternativas de tratamento se torne cada vez mais necessário.Processos oxidativos avançados (POA's), fundamentados na geração de radicais hidroxila, têm se mostrado promissores, pois são capazes de oxidar uma grande classe de compostos de difícil degradação.8 Dentre os POA's, o processo Fenton tem sido amplamente utilizado, devido ao baixo custo, ausência de toxidade dos reagentes (H 2 O 2 e Fe), além da simplicidade operacional. 8,9
ObstractThis article evaluates the efficiency of the degradation of pollutants present in water from the purification of biodiesel, characterized by high content of chemical oxygen demand (COD), suspended solids (SS), oils and greases, methanol, soap, and glycerol. The treatment process proposed was of the photo-Fenton type using iron immobilized in chitosan. The characterization of the material was performed according to degree of deacetylation (DD) and thermal stability (TG). The results revealed a DD of 66.5% and that the material undergoes decomposition in three temperature stages: 100; 150-350 and above 350 °C. The evaluated parameters were: COD, suspended solids, oils and greases, color and turbidity. After a 180-minutes long treatment, the removal percentage was 94.52, 70, 55, and 60% respectively. These results indicate that the photo-Fenton process can be an alternative for pre-treatment this type of effluent.
The generation of poly-hydroxilated transient species during the photochemical treatment of phenol usually impedes the spectrophotmetric monitoring of its degradation process. Frequently, the appearance of compounds such as pyrocatechol, hydroquinone and benzoquinone produces serious spectral interference, which hinder the use of the classical univariate calibration process. In this work, the use of multivariate calibration is proposed to permit the spectrophotometric determination of phenol in the presence of these intermediates. Using 20 synthetic mixtures containing phenol and the interferents, a calibration model was developed by using a partial least square regression process (PLSR) and processing the absorbance signal between 180 and 300 nm. The model was validated by using 3 synthetic mixtures. In this operation, typical errors lower than 3% were observed. Close correlation between the results obtained by liquid chromatography and the proposed method was also observed.
Com o aumento do consumo de combustíveis fósseis e problemas ambientais associados a sua queima, busca-se formas alternativas de energia limpa e renovável. O biodiesel é obtido a partir de qualquer tipo de oleaginosa ou até mesmo de óleos já utilizados. Objetivou-se neste estudo produzir biodiesel a partir da planta Cyperus esculentus bem como propor um tratamento alternativo para a água oriunda da etapa de purificação. Após a produção e extração dos ácidos graxos realizou-se o processo de transesterificação em catálise básica via rota metílica. Foram analisados os parâmetros físico-químicos: massa específica, pH, condutividade e ponto de fulgor para o biodiesel, DQO e turbidez para a água de lavagem. O tratamento adotado para a água foi o foto-Fenton em condições otimizadas. As propriedades físico-químicas para o biodiesel apresentaram-se dentro das normas da ANP. A água de lavagem apresentou DQO de 1.940 mg L-1 antes do tratamento. Após o tratamento, obteve-se eficiência de redução de DQO de 92%. Os resultados revelaram que a erva daninha mostrou-se promissora para produção de biodiesel e o processo de tratamento adota do possui elevado potencial de degradação dos resíduos gerados.
scite is a Brooklyn-based organization that helps researchers better discover and understand research articles through Smart Citations–citations that display the context of the citation and describe whether the article provides supporting or contrasting evidence. scite is used by students and researchers from around the world and is funded in part by the National Science Foundation and the National Institute on Drug Abuse of the National Institutes of Health.
hi@scite.ai
10624 S. Eastern Ave., Ste. A-614
Henderson, NV 89052, USA
Copyright © 2024 scite LLC. All rights reserved.
Made with 💙 for researchers
Part of the Research Solutions Family.