We describe evidence for a novel mechanism of monoclonal antibody (MAb)-directed nanoparticle (immunoliposome) targeting to solid tumors in vivo. Long-circulating immunoliposomes targeted to HER2 (ErbB2, Neu) were prepared by the conjugation of anti-HER2 MAb fragments (Fab ¶ or single chain Fv) to liposome-grafted polyethylene glycol chains. MAb fragment conjugation did not affect the biodistribution or long-circulating properties of i.v.-administered liposomes. However, antibody-directed targeting also did not increase the tumor localization of immunoliposomes, as both targeted and nontargeted liposomes achieved similarly high levels (7-8% injected dose/g tumor tissue) of tumor tissue accumulation in HER2-overexpressing breast cancer xenografts (BT-474). Studies using colloidal gold-labeled liposomes showed the accumulation of anti-HER2 immunoliposomes within cancer cells, whereas matched nontargeted liposomes were located predominantly in extracellular stroma or within macrophages. A similar pattern of stromal accumulation without cancer cell internalization was observed for anti-HER2 immunoliposomes in non-HER2-overexpressing breast cancer xenografts (MCF-7). Flow cytometry of disaggregated tumors posttreatment with either liposomes or immunoliposomes showed up to 6-fold greater intracellular uptake in cancer cells due to targeting. Thus, in contrast to nontargeted liposomes, anti-HER2 immunoliposomes achieved intracellular drug delivery via MAb-mediated endocytosis, and this, rather than increased uptake in tumor tissue, was correlated with superior antitumor activity. Immunoliposomes capable of selective internalization in cancer cells in vivo may provide new opportunities for drug delivery.

Liposome formulations of camptothecins have been actively pursued because of the potential for significant pharmacologic advantages from successful drug delivery of this important class of anticancer drugs. We describe nanoliposomal CPT-11, a novel nanoparticle/liposome construct containing CPT-11 (irinotecan) with unprecedented drug loading efficiency and in vivo drug retention. Using a modified gradient loading method featuring a sterically hindered amine with highly charged, multivalent anionic trapping agents, either polymeric (polyphosphate) or nonpolymeric (sucrose octasulfate), liposomes were capable of entrapping CPT-11 at extremely high drug-to-lipid ratios (>800 g CPT-11/mol phospholipid) and retaining encapsulated drug in vivo with a half-life of drug release in the circulation of 56.8 hours. CPT-11 was also protected from hydrolysis to the inactive carboxylate form and from metabolic conversion to SN-38 while circulating. The maximum tolerated dose in normal mice was determined to be 80 mg/kg for free CPT-11 and >320 mg/kg for nanoliposomal CPT-11. Nanoliposomal CPT-11 showed markedly superior efficacy when compared with free CPT-11 in human breast (BT474) and colon (HT29) cancer xenograft models. This study shows that intraliposomal stabilization of CPT-11 using a polymeric or highly charged, nonpolymeric polyanionic trapping agent results in a markedly active antitumor agent with low toxicity. (Cancer Res 2006; 66(6): 3271-7)

Liposomes (70-100 nm) of 1-palmitoyl-2-oleoylphosphatidylcholine, cholesterol, and poly(ethylene glycol) (PEG)-modified phosphatidylethanolamine (PEG-DSPE) were conjugated to Fab' fragments of a humanized recombinant MAb against the extracellular domain of HER2/neu to create sterically stabilized immunoliposomes (anti-HER2 SL) as a drug carrier targeting HER2-overexpressing cancers. Conjugation employed maleimide-terminated membrane-anchored spacers of two kinds: a short spacer, providing attachment of Fab' close to the liposome bilayer, or a long spacer, with Fab' attachment at the distal terminus of the PEG chain. Confocal microscopy and spectrofluorometry of HER2-overexpressing breast cancer cells incubated with fluorescently labeled anti-HER2 SL prepared with either spacer showed binding of liposomes (8000-23000 vesicles/cell) followed by endocytosis (rate constant ke = 0.012-0.033 min-1) via the coated-pit pathway, evidenced by intracellular acidification and colocalization with transferrin. Uptake of anti-HER2 immunoliposomes by breast cancer cells with low HER2 expression, or after preincubation of cells with free anti-HER2 Fab', was less than 0.2% and 4.3%, respectively, of the uptake by HER2-overexpressing cells. Increasing PEG-DSPE content (up to 5.7 mol %) in anti-HER2-SL prepared with the short spacer decreased liposome-cell binding affinity 60-100-fold, while ke decreased only 2-fold; however, when Fab' fragments were conjugated via a PEG spacer, both binding affinity and ke were unaffected by PEG-DSPE content. Cell binding and internalization of anti-HER2 immunoliposomes increased at higher surface density of conjugated Fab' fragments, reaching plateaus at approximately 40 Fab'/liposome for binding and approximately 10-15 Fab'/liposome for internalization. Uptake of anti-HER2 immunoliposomes correlated with the cell surface density of HER2 and significantly (p < 0.005) correlated with the antiproliferative effect of the targeting antibody but not with the total level of cellular HER2 expression. The results obtained were used to optimize in vivo preclinical studies of anti-HER2 SL loaded with antineoplastic drugs.

We previously reported the development of epidermal growth factor receptor (EGFR)-targeted immunoliposomes that bind and internalize in tumor cells which overexpress EGFR and/or mutant EGFR variant III (EGFRvIII), enabling intracellular delivery of potent anticancer agents in vitro. We now describe in vivo proof-of-concept for this approach for the delivery of multiple anticancer drugs in EGFR-overexpressing tumor models. Anti-EGFR immunoliposomes were constructed modularly with FabVfragments of cetuximab (IMC-C225), covalently linked to liposomes containing probes and/or anticancer drugs. Pharmacokinetic and biodistribution studies confirmed long circulation times (t 1/2 = 21 hours) and efficient accumulation in tumors (up to 15% ID/g) irrespective of the presence of the targeting ligand. Although total accumulations of anti-EGFR immunoliposomes and nontargeted liposomes in EGFR-overexpressing tumors were comparable, only immunoliposomes internalized extensively within tumor cells (92% of analyzed cells versus <5% for nontargeted liposomes), indicating different mechanisms of delivery at the cellular level. In vivo therapy studies in a series of xenograft models featuring overexpression of EGFR and/or EGFRvIII showed the superiority of immunoliposomal delivery of encapsulated drugs, which included doxorubicin, epirubicin, and vinorelbine. For each of these drugs, anti-EGFR immunoliposome delivery showed significant antitumor effects and was significantly superior to all other treatments, including the corresponding free or liposomal drug (P < 0.001-0.003). We conclude that anti-EGFR immunoliposomes provide efficient and targeted drug delivery of anticancer compounds and may represent a useful new treatment approach for tumors that overexpress the EGFR. (Cancer Res 2005; 65(24): 11631-8)

Stable complexes of cationic liposomes with plasmid DNA were prepared by (1) including a small amount of poly(ethylene glycol)-phospholipid conjugate or (2) condensing the DNA with polyamines prior to the formation of liposomeplasmid complexes. These preparations were stable for months at 4°C and gave reproducible high transfection activity for in vivo gene delivery after intravenous injection in mice. Under these conditions, the expression of marker gene (luciferase) was primarily in the lungs (reaching values up to 3 ng expression per mg tissue protein), but also in other tissues to a lesser extent. Non-stabilized formulations lost all their transfection activity in 4 days. In these formulations cholesterol, not dioleoylphosphatidylethanolamine, was the helper lipid effective for sustaining high transfection activity in vivo. These new developments in formulation technology should enhance the potential for liposome-mediated gene therapy.