Efficient light to biomass conversion in photobioreactors is crucial for economically feasible microalgae production processes. It has been suggested that photosynthesis is enhanced in short light path photobioreactors by mixing-induced flashing light regimes. In this study, photosynthetic efficiency and growth of the green microalga Chlamydomonas reinhardtii were measured using LED light to simulate light/dark cycles ranging from 5 to 100 Hz at a light-dark ratio of 0.1 and a flash intensity of 1000 µmol m(-2) s(-1). Light flashing at 100 Hz yielded the same photosynthetic efficiency and specific growth rate as cultivation under continuous illumination with the same time-averaged light intensity (i.e., 100 µmol m(-2) s(-1)). The efficiency and growth rate decreased with decreasing flash frequency. Even at 5 Hz flashing, the rate of linear electron transport during the flash was still 2.5 times higher than during maximal growth under continuous light, suggesting storage of reducing equivalents during the flash which are available during the dark period. In this way the dark reaction of photosynthesis can continue during the dark time of a light/dark cycle. Understanding photosynthetic growth in dynamic light regimes is crucial for model development to predict microalgal photobioreactor productivities.

To be able to study the effect of mixing as well as any other parameter on productivity of algal cultures, we designed a lab-scale photobioreactor in which a short light path (SLP) of (12 mm) is combined with controlled mixing and aeration. Mixing is provided by rotating an inner tube in the cylindrical cultivation vessel creating Taylor vortex flow and as such mixing can be uncoupled from aeration. Gas exchange is monitored on-line to gain insight in growth and productivity. The maximal productivity, hence photosynthetic efficiency, of Chlorella sorokiniana cultures at high light intensities (1,500 micromol m(-1) s(-1)) was investigated in this Taylor vortex flow SLP photobioreactor. We performed duplicate batch experiments at three different mixing rates: 70, 110, and 140 rpm, all in the turbulent Taylor vortex flow regime. For the mixing rate of 140 rpm, we calculated a quantum requirement for oxygen evolution of 21.2 mol PAR photons per mol O(2) and a yield of biomass on light energy of 0.8 g biomass per mol PAR photons. The maximal photosynthetic efficiency was found at relatively low biomass densities (2.3 g L(-1)) at which light was just attenuated before reaching the rear of the culture. When increasing the mixing rate twofold, we only found a small increase in productivity. On the basis of these results, we conclude that the maximal productivity and photosynthetic efficiency for C. sorokiniana can be found at that biomass concentration where no significant dark zone can develop and that the influence of mixing-induced light/dark fluctuations is marginal.

As a result of mixing and light attenuation in a photobioreactor (PBR), microalgae experience light/dark (L/D) cycles that can enhance PBR efficiency. One parameter which characterizes L/D cycles is the duty cycle; it determines the time fraction algae spend in the light. The objective of this study was to determine the influence of different duty cycles on oxygen yield on absorbed light energy and photosynthetic oxygen evolution. Net oxygen evolution of Chlamydomonas reinhardtii was measured for four duty cycles (0.05, 0.1, 0.2, and 0.5) in a biological oxygen monitor (BOM). Oversaturating light flashes were applied in a square-wave fashion with four flash frequencies (5, 10, 50, and 100 Hz). Algae were precultivated in a turbidostat and acclimated to a low photon flux density (PFD). A photosynthesis-irradiance (PI) curve was measured under continuous illumination and used to calculate the net oxygen yield, which was maximal between a PFD of 100 and 200 μmol m⁻² s⁻¹. Net oxygen yield under flashing light was duty cycle-dependent: the highest yield was observed at a duty cycle of 0.1 (i.e., time-averaged PFD of 115 μmol m⁻² s⁻¹). At lower duty cycles, maintenance respiration reduced net oxygen yield. At higher duty cycles, photon absorption rate exceeded the maximal photon utilization rate, and, as a result, surplus light energy was dissipated which led to a reduction in net oxygen yield. This behavior was identical with the observation under continuous light. Based on these data, the optimal balance between oxygen yield and production rate can be determined to maximize PBR productivity.

As a result of mixing and light attenuation, algae in a photobioreactor (PBR) alternate between light and dark zones and, therefore, experience variations in photon flux density (PFD). These variations in PFD are called light/dark (L/D) cycles. The objective of this study was to determine how these L/D cycles affect biomass yield on light energy in microalgae cultivation. For our work, we used controlled, short light path, laboratory, turbidostat-operated PBRs equipped with a LED light source for square-wave L/D cycles with frequencies from 1 to 100 Hz. Biomass density was adjusted that the PFD leaving the PBR was equal to the compensation point of photosynthesis. Algae were acclimated to a sub-saturating incident PFD of 220 µmol m(-2) s(-1) for continuous light. Using a duty cycle of 0.5, we observed that L/D cycles of 1 and 10 Hz resulted on average in a 10% lower biomass yield, but L/D cycles of 100 Hz resulted on average in a 35% higher biomass yield than the yield obtained in continuous light. Our results show that interaction of L/D cycle frequency, culture density and incident PFD play a role in overall PBR productivity. Hence, appropriate L/D cycle setting by mixing strategy appears as a possible way to reduce the effect that dark zone exposure impinges on biomass yield in microalgae cultivation. The results may find application in optimization of outdoor PBR design to maximize biomass yields.